Special Oil & Gas Reservoirs >

2020 , Vol. 27 >Issue 5: 106 - 112

DOI: https://doi.org/10.3969/j.issn.1006-6535.2020.05.016

Reservoir Engineering

Research on Gel Particles + Polymer Flooding Technology for Quaternary Oil Recovery in Daqing Oilfield

  • Chen Wenlin
Expand
  • E& R Research Insitute of Daqing Oilfield Co., Ltd., CNPC, Daqing, Heilongjian 163712, China

Received date: 2019-11-18

  Revised date: 2020-06-28

  Online published: 2022-02-18

Fold

Abstract

After polymer flooding in Daqing Oilfield, the dominate seepage channels were very developed in the reservoir, the three major interferences, that is interlayer interference, inner layer interference and plane interference, intensified, the consumption of high-concentration polymer for flooding grew, and the economic benefits declined. In view of these problems, PPG gel particles were developed independently, and the PPG+polymer flooding technology were established, realizing the organic combination of "plugging, adjusting and flooding". Through experimental methods such as instrument detection and physical simulation, etc., the seepage characteristics and oil displacement effect of PPG+polymer system were analyzed, and the optimal system formula and injection pattern were screened. The research results show that: PPG for flooding control can increase viscosity, and viscosity retention rate of PPG+polymer system for flooding is as high as 78.9% after 90 days. Compared with pure polymer solution, the viscoelasticity of PPG+polymer system increases significantly, and the system has stronger plugging control properties. The optimal flooding effect can be achieved by firstly injecting PPG+polymer for plugging control with 0.05 PV and then injecting PPG+polymer for flooding control with 0.70 PV, which can save polymer consumption by 24%. After implementing PPG+polymer system for flooding control to the blocks for research and prediction, the recovery rate has increased by 8.57 percentage points. The research can provide technical support for continuous and efficient development of quaternary oil recovery stage.

Key words： quaternary oil recovery; PPG+polymer system; viscoelasticity; flooding control; Daqing Oilfield

Cite this article

Chen Wenlin . Research on Gel Particles + Polymer Flooding Technology for Quaternary Oil Recovery in Daqing Oilfield[J]. Special Oil & Gas Reservoirs, 2020 , 27(5) : 106 -112 . DOI: 10.3969/j.issn.1006-6535.2020.05.016

References

[1] 郭尚平,田根林,王芳,等.聚合物驱后进一步提高采收率的四次采油问题[J].石油学报,1997,18(4):49-53.
GUO Shangping,TIAN Genlin,WANG Fang,et al.The problem of quaternary oil recovery succeeding a polymer flooding[J].Acta Petrolei Sinica,1997,18(4):49-53.
[2] 高淑玲.聚驱后剩余油分布规律及剩余储量潜力分析[J].大庆石油地质与开发,2011,30(5):125-129.
GAO Shuling.Laws of residual oil distribution and the analysis of remained reserves potential after polymer flooding[J].Petroleum Geology & Oilfield Development in Daqing,2011,30(5):125-129.
[3] 汪萍,常毓文,唐玮,等.聚合物驱油后提高采收率优化研究[J].特种油气藏,2011,18(4):73-76.
WANG Ping,CHANG Yuwen,TANG Wei,et al.EOR optimization after polymer flooding[J].Special Oil & Gas Reservoirs,2011,18(4):73-76.
[4] 韩培慧,赵群,穆爽书,等.聚合物驱后进一步提高采收率途径的研究[J].大庆石油地质与开发,2006,25(5):81-84.
HAN Peihui,ZHAO Qun,MU Shuangshu,et al.Study on further EOR after polymer flooding[J].Petroleum Geology & Oilfield Development in Daqing,2006,25(5):81-84.
[5] 刘海波.大庆油区长垣油田聚合物驱后优势渗流通道分布及渗流特征[J].油气地质与采收率,2014,21(5):69-72.
LIU Haibo.Dominant flowing channels distribution and seepage characteristics after polymer flooding in Daqing Oilfield[J].Petroleum Geology and Recovery Efficiency,2014,21(5):69-72.
[6] 曹瑞波,韩培慧,高淑玲.不同驱油剂应用于聚合物驱后油层的适应性分析[J].特种油气藏,2012,19(4):100-104.
CAO Ruibo,HAN Peihui,GAO Shuling.Reservoir adaptability analysis of different oil displacement agents in polymer flooding[J].Special Oil & Gas Reservoirs,2012,19(4):100-104.
[7] 韩培慧,曹瑞波.聚驱后井网加密与二元复合驱结合提高采收率实验研究[J].海洋石油2013,33(1):59-63.
HAN Peihui,CAO Ruibo.Experimental study on infilling well and combined EOR methods by s/p binary flooding after polymer flooding[J] .Offshore Oil,2013,33(1):59-63.
[8] 高淑玲.聚驱后残留聚合物对提高采收率的影响[J].大庆石油地质与开发,2014,33(6):113-117.
GAO Shuling.Influences of the residual polymer on the enhanced recovery after the polymer flooding[J].Petroleum Geology & Oilfield Development in Daqing,2014,33(6):113-117.
[9] 白振强,吴胜和,付志国.大庆油田聚合物驱后微观剩余油分布规律[J].石油学报,2013,34(5):924-931.
BAI Zhenqiang,WU Shenghe,FU Zhiguo.The distribution of microcosmic remaining oils after polymer flooding in Daqing Oilfield[J].Acta Petrolei Sinica,2013,34(5):924-931.
[10] 王正波,叶银珠,王继强.聚合物驱后剩余油研究现状及发展方向[J].油气地质与采收率,2010,17(4):37-42.
WANG Zhengbo,YE Yinzhu,WANG Jiqiang.Review on status and prospect of residual oil study after polymer flooding[J].Petroleum Geology and Recovery Efficiency,2010,17(4):37-42.
[11] 白宝君,刘伟,李良雄,等.影响预交联凝胶颗粒性能特点的内因分析[J].石油勘探与开发,2002,29(2):103-105.
BAI Baojun,LIU Wei,LI Liangxiong,et al.An analysis on intrinsic factors influencing the properties of pre-crosslinking gelled particles[J].Petroleum Exploration and Development,2002,29(2):103-105.
[12] 鲁娇,彭勃,李明远,等.预交联聚丙烯酰胺分散体系的制备及封堵性能[J].石油学报,2010,26(5):800-805.
LU Jiao,PENG Bo,LI mingyuan,et al.Preparation and plugging properties of pre-crosslinked polyacrylamide dispersion[J].Acta Petrolei Sinica,2010,26(5):800-805.
[13] 夏惠芬,王德民,关庆杰,等.聚合物溶液的粘弹性实验[J].大庆石油学院学报,2002,26(2):105-108.
XIA Huifen,WANG Demin,GUAN Qingjie,et al.Experiment of viscoelasticity of polymer solution[J].Journal of Daqing petroleum institute,2002,26(2):105-108.
[14] 夏惠芬,岳湘安,曹广胜,等.渗流过程中聚合物溶液的流变性[J].大庆石油学院学报,2000,24(3):26-29.
XIA Huifen,YUE Xiang'an,CAO Guangsheng,et al.Rheological behavior of polymer solution in the course of seepage flow[J].Journal of Daqing Petroleum Institute,2000,24(3):26-29.
[15] 谢全,蒲万芬,刑杨梅,等.预交联凝胶封堵性实验研究[J].特种油气藏,2006,13(4):92-93,103.
XIE Quan,PU Wanfen,XING Yangmei.Experimental study on seal-off behavior of pre-crosslinked gel[J].Special Oil & Gas Reservoirs,2006,13(4):92,93,103.
[16] 刘一江,刘积松,李琇富.预交联凝胶微粒在深度调剖中的应用[J].油气地质与采收率,2001,8(3):65-66.
LIU Yijiang,LIU Jisong,LI Xiufu.Application of pre-crosslinked gel particles to depth profile control[J].Petroleum Geology and Recovery Efficiency,2001,8(3):65-66.
[17] 刘煜.黏弹性颗粒驱油剂注入性能研究[J].西安石油大学学报(自然科学版),2016,31(5):60-63,83.
LIU Yu.Study on injection performance of viscoelastic particle displacement agent (preformed particle gel (PPG))[J].Journal of Xi'an Shiyou University(Natural Science Edition),2016,31(5):60-63,83.
[18] 崔晓红.新型非均相复合驱油方法[J].石油学报,2011,32(1):122-126.
CUI Xiaohong.A study on the heterogeneous combination flooding system[J].Acta Petrolei Sinica,2011,32(1):122-126.
[19] 雷锡岳,曲占庆,郝彤,等.聚合物驱后复合相态调驱体系提高采收率技术[J].特种油气藏,2018,25(2):143-147.
LEI Xiyue,QU Zhanqing,HAO Tong,et al.Composite profile-control flooding to enhance oil recovery after polymer flooding[J].Special Oil & Gas Reservoirs,2018,25(2):143-147.
[20] 任亭亭,宫厚健,桑茜,等.聚驱后B-PPG与HPAM非均相复合驱提高采收率技术[J].西安石油大学学报(自然科学版),2015,30(5):54-58,84.
REN Tingting,GONG Houjian,SANG Qian,et al.Enhanced oil recovery by HPAM/B-PPG heterogeneous composite flooding after polymer flooding[J].Journal of Xi'an Shiyou University(Natural Science Edition),2015,30(5):54-58,84.
[21] 于龙,李亚军,宫厚健,等.非均质油层聚合物驱后黏弹性支化预交联凝胶颗粒驱提高采收率技术[J].油气地质与采收率,2016,23(1):113-118.
YU Long,LI Yajun,GONG Houjian,et al.EOR of branched-preformed particle gel (B-PPG)flooding after polymer flooding in heterogeneous reservoirs[J].Petroleum Geology and Recovery Efficiency,2016,23(1):113-118.
[22] 曹伟东,戴涛,于金彪.非均相复合驱数值模拟方法研究与应用[J].石油与天然气地质,2016,37(4):606-611.
CAO Weidong,DAI Tao,YU Jinbiao.A numerical simulation method of heterogeneous combination flooding[J].Oil & Gas Geology,2016,37(4):606-611.
[23] 赵秀娟,左松林,吴家文,等.大庆油田特高含水期层系井网重构技术研究与应用[J].油气地质与采收率,2019,26(4):82-87.
ZHAO Xiujuan,ZUO Songlin,WU Jiawen,et al.Study and application of strata & well pattern reconstruction technique at extra high water cut stage in Daqing Oilfield[J].Petroleum Geology and Recovery Efficiency,2019,26(4):82-87.
Options
Outlines

/

〈 〉