Special Oil & Gas Reservoirs >

2023 , Vol. 30 >Issue 3: 88 - 96

DOI: https://doi.org/10.3969/j.issn.1006-6535.2023.03.011

Reservoir Engineering

Experimental Study on Direct Current Enhanced Oil Recovery Technology for Tight Reservoirs

  • Jia Zejiang ,
  • Ning Zhengfu ,
  • Zhang Wentong ,
  • Mao Zhu ,
  • Wang Zhipeng ,
  • Cheng Zhilin
Expand
  • 1. State Key Laboratory of Oil and Gas Resources and Exploration,Beijing 102249, China;
    2. China University of Petroleum (Beijing),Beijing 102249, China;
    3. Xi'an Shiyou University, Xi'an, Shaanxi 710065, China

Received date: 2022-06-01

  Revised date: 2023-02-20

  Online published: 2023-07-13

Fold

Abstract

To address the problem of poor development due to difficult water injection in tight oil, the application of DC electric field is proposed to enhance the recovery of tight oil. Taking the tight sandstone core of the Upper Triassic Yanchang Formation in the Ordos Basin as the research object, the DC electric field displacement effect and the mechanism of action were investigated through DC electric field constant velocity displacement experiments, wetting angle measurements and XRD test experiments. The study shows that the DC electric field enhanced recovery rate of tight oil is positively correlated with the electric field intensity; the development effect when the DC electric field is applied at the beginning of water flooding is better than that when the DC electric field is applied after the end of water flooding, both of which can increase the average recovery rate through water flooding by 29.06 and 14.68 percentage points respectively at 10 V; the recovery rate is accelerated after the DC electric field is applied; the DC electric field can not only reduce the flow resistance through electroosmotic flow to decrease the difficulty of water injection, but also enhance the hydrophilicity of the rock through electrochemical reaction to improve the oil displacement efficiency. The study provides a new idea for the efficient development of tight oil.

Key words： DC electric field; tight sandstone; water content; wettability; enhanced oil recovery

Cite this article

Jia Zejiang , Ning Zhengfu , Zhang Wentong , Mao Zhu , Wang Zhipeng , Cheng Zhilin . Experimental Study on Direct Current Enhanced Oil Recovery Technology for Tight Reservoirs[J]. Special Oil & Gas Reservoirs, 2023 , 30(3) : 88 -96 . DOI: 10.3969/j.issn.1006-6535.2023.03.011

References

[1] 肖前华.典型致密油区储层评价及渗流机理研究[D].北京:中国科学院研究生院(渗流流体力学研究所), 2015.
XIAO Qianhua.Study on reservoir evaluation and seepage mechanism of typical tight oil area[D].Beijing:University of Chinese Academy of Sciences(Research Institute of Seepage Fluid Mechanics),2015.
[2] 赵华伟.致密油储层微观孔隙结构及渗流规律研究[D].北京:中国石油大学(北京), 2017.
ZHAO Huawei.Study on microscopic pore structure and seepage law of tight oil reservoir[D].Beijing:China University of Petroleum (Beijing),2017.
[3] 孙龙德, 邹才能, 贾爱林, 等.中国致密油气发展特征与方向[J].石油勘探与开发, 2019, 46(6):1015-1026.
SUN Longde,ZOU Caineng,JIA Ailin,et al.Development characteristics and orientation of tight oil and gas in China[J].Petroleum Exploration and Development,2019,46(6):1015-1026.
[4] 秦正山, 周建良, 谢晶.致密砂岩油藏注表面活性剂驱油体系提高采收率实验[J].断块油气田, 2020, 27(5):628-632.
QIN Zhengshan,ZHOU Jianliang,XIE Jing.Experiment on enhanced oil recovery by surfactant-injection oil displacement system in tight sandstone reservoirs[J].Fault-Block Oil & Gas Field,2020,27(5):628-632.
[5] 李士伦, 汤勇, 侯承希.注CO2提高采收率技术现状及发展趋势[J].油气藏评价与开发, 2019, 9(3):1-8.
LI Shilun,TANG Yong,HOU Chengxi.Present situation and development trend of CO2 injection enhanced oil recovery technology[J].Reservoir Evaluation and Development,2019,9(3):1-8.
[6] 陈斌, 唐恩高, 黄波,等.低矿化度水驱提高原油采收率的机理分析及研究进展[J].中外能源, 2020, 25(6):39-45.
CHEN Bin,TANG Engao,HUANG Bo,et al.Mechanism analysis and research progress on low salinity water flooding[J].Sino-Global Energy,2020,25(6):39-45.
[7] KIRBY B J.Micro and nanoscale fluid mechanics:transport in microfluidic devices[M].Cambridge:Cambridge University press,2010,1-536.
[8] SOONG C Y,HWANG P W,WANG J C.Analysis of pressure-driven electrokinetic flows in hydrophobic microchannels with slip-dependent zeta potential[J].Microfluidics & Nanofluidics,2010,9(2/3):211-223.
[9] BOWEN W R,JENNER F.Electroviscous effects in charged capillaries[J].Journal of Colloid & Interface Science,1995,173(2):388-395.
[10] YANG C,LI D Q.Analysis of electrokinetic effects on the liquid flow in rectangular microchannels[J].Colloids and Surfaces A Physicochemical and Engineering Aspects,1998,143(2/3):339-353.
[11] YANG J,KWOK D Y.Microfluid flow in circular microchannel with electrokinetic effect and navier's slip condition[J].Langmuir,2003,19(4):1047-1053.
[12] 张宁生.电化学采油及其作用机理综述[J].石油勘探与开发, 1998, 25(2):57-58.
ZHANG Ningsheng.A discussion on the electrochemical recovery method and its mechanism[J].Petroleum Exploration and Development,1998,25(2):57-58.
[13] 关继腾, 陈月明, 王玉斗.直流电动-水动力驱油机理研究[J].石油大学学报(自然科学版), 2000, 24(5):23-27.
GUAN Jiteng,CHEN Yueming,WANG Yudou.Mechanisms of electrokinetic-water-flooding[J].Journal of China University of Petroleum(Edition of Natural Science),2000,24(5):23-27.
[14] GHOSH B,SHALABI E W A,HAROUN M.The effect of DC electrical potential on enhancing sandstone reservoir permeability and oil recovery[J].Liquid Fuels Technology,2012,30(20):2148-2159.
[15] ANSARI A,HAROUN M,AL KINDY N,et al.Electrokinetics assisted surfactant-EOR to optimize mature waterfloods in AbuDhabi carbonate reservoirs[C].SPE165909-MS,2013:1-23.
[16] DAS S K.Electro-magnetic heating in viscous oil reservoir[C].SPE117693-MS,2008:1-11.
[17] HILL D G,CHILINGAR G V,WITTLE J K.Direct current electrical enhanced oil recovery in heavy-oil reservoirs to improve recovery,reduce water cut,and reduce H2S production while increasing API gravity[C].SPE114012-MS,2008:1-19.
[18] PENNY S,KARANIKAS J M,BARNETT J,et al.Field case studies of downhole electric heating in two horizontal Alberta heavy oil wells[C].SPE196187-MS,2019:1-19.
[19] PIZARRO J O S,TREVISAN O V.Electrical heating of oil reservoirs:numerical simulation and field test results[J].Journal of Petroleum Technology,1990,42(10):1320-1326.
[20] WITTLE J K,HILL D G,CHILINGAR G V.Direct electric current oil recovery(EEOR)-a new approach to enhancing oil production[J].Energy Sources,Part A:Recovery,Utilization,and Environmental Effects,2011,33(9):805-822.
[21] 张永超.致密砂岩中的润湿性及其对石油运移和聚集的影响研究[D].北京:中国石油大学(北京),2019.
ZHANG Yongchao.Study on wettability in tight sandstone and its effect on oil transport and aggregation[D].Beijing:China University of Petroleum(Beijing),2019.
[22] 薄小松,斯尚华,周小英.岩石矿物组成及地层水性质对致密砂岩润湿性的影响[J].西部探矿工程, 2020, 32(11):100-102, 111.
BO Xiaosong,SI Shanghua,ZHOU Xiaoying.Influence of rock mineral composition and stratigraphic water properties on the wettability of tight sandstone[J].West-China Exploration Engineering,2020,32(11):100-102,111.
[23] CHENG Z L,NING Z F,DAI S.The electroviscous flow of Non-Newtonian fluids in microtubes and implications for nonlinear flow in porous media[J].Journal of Hydrology,2020,590(1/2):125224.
[24] GODINEZ-BRIZUELA O E,NIASAR V J.Simultaneous pressure and electro-osmosis driven flow in charged porous media:pore-scale effects on mixing and dispersion[J].Journal of Colloid and Interface Science,2020,561:162-172.
[25] MO X B,HU X G.Electroviscous effect on pressure driven flow and related heat transfer in microchannels with surface chemical reaction[J].International Journal of Heat & Mass Transfer,2019,130:813-820.
[26] PAMUK CU S.Electrochemical technologies for petroleum contaminated soils[J].Electrochemically Assisted Remediation of Contaminated Soils,2021,30:455-488.
[27] TINA P,ALEKSANDR M,ZZHRA A,et al.Role of kaolinite clay minerals in enhanced oil recovery by low salinity water Injection[J].Energy & Fuels,2018,32(7):7374-7382.
[28] ZHANG W T,NING Z F,CHENG Z L,et al.Experimental investigation of the role of DC voltage in the wettability alteration in tight sandstones[J].Langmuir,2020,36(40):11985-11995.
[29] 单祥,郭华军,陈希光,等. 低渗透致密砂岩储集层致密化成因——以准噶尔盆地莫北—莫索湾凸起下侏罗统八道湾组为例[J]. 新疆石油地质,2021,42(1):29-37.
SHAN Xiang, GUO Huajun, CHEN Xiguang,et al. Genesis of densification of low-permeability tight sandstone reservoirs: a case study of Lower Jurassic Badaowan formation in Mobei-Mosuowan Swell, Junggar Basin[J].Xinjiang Petroloeum Geology, 2021,42(1):29-37.
[30] 李新勇,吴恒川,房好青,等.微观结构差异对碳酸盐岩酸蚀损伤的影响[J].新疆石油地质,2021,42(2):188-193.
LI Xinyong, WU Hengchuan,FANG Haoqing,et al. Influences of microstructural differences on acid corrosive damage to carbonate rocks[J]. Xinjiang Petroleum Geology,2021,42(2):188-193.
Options
Outlines

/

〈 〉