Special Oil & Gas Reservoirs >

2024 , Vol. 31 >Issue 1: 123 - 130

DOI: https://doi.org/10.3969/j.issn.1006-6535.2024.01.016

Reservoir Engineering

Effect of Brine on Asphaltene Precipitation in Emulsions of Water Flooding Reservoirs

  • Song Jun ,
  • Li Haiyan ,
  • Song Wei ,
  • Liu Yifei ,
  • Li Jinhai ,
  • Pan Yuewen ,
  • Liu Junlong
Expand
  • PetroChina Qinghai Oilfield Company,Haixi,Qinghai 816400, China

Received date: 2023-04-17

  Revised date: 2023-12-20

  Online published: 2024-04-18

Fold

Abstract

Water-in-oil emulsions are very easy to form in reservoir water injection development, and the mechanism of the effect of brine on asphaltene precipitation in emulsions is not clear. To address the above problems, based on the self-made experimental oil and water-in-oil emulsions, static centrifugal experiments and dynamic displacement experiments were carried out by spectrophotometry and simultaneous oil-water injection method, respectively, to study the effects of water cut, salt type, and salt mass concentration on asphaltene precipitation in emulsions, and reveal the mechanism of asphaltene precipitation under the action of salt water. Research shows that when the water cut in emulsion increases from 10% to 50%, the asphaltene instability increases and the mass fraction of precipitation increases from 4.5% to 10.6%, but the precipitation intensity weakens. Asphaltenes with low aromaticity are more likely to precipitate at the water/oil interfaces mainly because of adsorption by heteroatoms on the water surfaces at the interface. Asphaltene precipitation tends to increase and decrease with the increase of salt mass concentration, reaching the maximum when the salt mass concentration reaches 40 000 mg/L. MgCl2, CaCl2, NaCl, and KCl affect the amount of asphaltene precipitation from high to low. The emulsion with a 40% volumetric concentration of distilled water shows the most significant decrease in permeability during the flooding, followed by a 20% mass concentration of MgCl2 emulsion, while the 20% distilled water and 20% NaCl emulsions show the smallest decrease in permeability. The effect of brine on asphaltene precipitation in the dynamic displacement is smaller than that in the static experiment. Still, the increase in water cut increases asphaltene precipitation and decreases core permeability. The research results are significant in improving the development effect of water injection in asphaltene reservoirs.

Key words： emulsion; asphaltene precipitation; salt mass concentration; water flooding reservoir; permeability; absorbance

Cite this article

Song Jun , Li Haiyan , Song Wei , Liu Yifei , Li Jinhai , Pan Yuewen , Liu Junlong . Effect of Brine on Asphaltene Precipitation in Emulsions of Water Flooding Reservoirs[J]. Special Oil & Gas Reservoirs, 2024 , 31(1) : 123 -130 . DOI: 10.3969/j.issn.1006-6535.2024.01.016

References

[1]周晋冲,张彬,雷征东,等.低渗透油藏不稳注水岩心实验及增油机理[J].新疆石油地质,2022,43(4):491-495.
ZHOU Jinchong,ZHANG Bin,LEI Zhengdong,et al.Core experiment and stimulation mechanism of unstable waterflooding in low permeability reservoirs[J].Xinjiang Petroleum Geology,2022,43(4):491-495.
[2]雷浩.低渗储层CO2驱油过程中沉淀规律及防治对策研究[D].北京:中国石油大学(北京),2017.
LEI Hao.Deposition mechanisms and reservoir protection countermeasures of a low-permeability formation in CO2 flooding process[D].Beijing: China University of Petroleum(Beijing),2017.
[3]GOLKARI A, RIAZI M.Experimental investigation of miscibility conditions of dead and live asphaltenic crude oil CO2 systems[J].Journal of Petroleum Exploration and Production Technology,2017,7(2):597-609.
[4]ALIZADEH S, SULEYMANI M. A mechanistic study of emulsion flooding for mobility control in the presence of fatty acids: effect of chain length [J].Fuel,2020,276:110-118.
[5]文江波,罗海军.原油-水两相体系乳化特性研究进展[J].科学技术与工程,2021,21(17):6971-6979.
WEN Jiangbo,LUO Haijun.Progress in studies of emulsification of crude oil-water two-phase system[J].Science Technology and Engineering,2021,21(17),6971-6979.
[6]赵一潞,康万利,殷夏,等.长庆油包水乳状液的稳定性与沥青质含量的关系[J].石油学报(石油加工),2018,34(3):592-599.
ZHAO Yilu,KANG Wanli,Yin Xia,et al.Relationship between the stability of Changqing water in oil emulsions and asphaltene content[J].Acta Petrolei Sinica(Petroleum Processing Section),2018,34(3):592-599.
[7]TCHOUKOV P,YANG F,XU Z,et al.Role of asphaltenes in stabilizing thin liquid emulsion films[J]. Langmuir,2014,30(11):3024-3033.
[8]SZTUKOWSKI D M,JAFARI M,ALBOUDWAREJ H, et al. Asphaltene self-association and water-in-hydrocarbon emulsions [J].Journal of Colloid Interface Science, 2003, 265(1): 179-186.
[9]TAVAKKOLI M,CHEN A,SUNG C A,et al.Effect of emulsified water on asphaltene instability in crude oils[J].Energy & Fuels,2016,30(5):3676-3686.
[10] ASLAN S, FIROOZABADI A.Effect of water on deposition, aggregate size, and viscosity of asphaltenes[J].Langmuir,2014,30(13):3658-3664.
[11] SINA A, BAHRAM S S. Experimental investigation of the brine effect on asphaltene precipitation and deposition during water injection in porous media using static and dynamic system[J].Energy & Fuels,2021,35(2):11141-11153.
[12] LING N N,HABER A,GRAHAM B F,et al.Quantifying the effect of salinity on oilfield water-in-oil emulsion stability[J].Energy & Fuels,2018,32(9):10042-10049.
[13] KUNDU P, AGRAWAL A, MATEEN H, et al. Stability of oil in water macro-emulsion with anionic surfactant: effect of electrolytes and temperature[J].Chemical Engineering and Science,2013,102(6):176-185.
[14] SAFARI M, RAHIMI A, GHOLAMI R, et al. Underlying mechanisms of shale wettability alteration by low salinity water injection (LSWI)[J].Journal of Dispersion Science Technology,2020,12(3):11-19.
[15] WEN J,LUO H,LONG Z,et al.Emulsification behaviors of crude oil-water system and its quantitative relationship with exergy loss rate[J].Journal of Petroleum Science and Engineering,2019,176(5):502-508.
[16] 唐梅荣,张同伍,白晓虎,等.孔喉结构对CO2驱储层伤害程度的影响[J].岩性油气藏,2019,31(3):1-8.
TANG Meirong,ZHANG Tongwu,BAI Xiaohu,et al.Influence of pore throat structure on reservoir damage with CO2 flooding[J].Lithologic Reservoirs,2019,31(3):1-8.
[17] MEHANA M, ABRAHAM J, FAHES M. The impact of asphaltene deposition on fluid flow in sandstone[J].Journal of Petroleum Science and Engineering,2019,174(4):676-681.
[18] 伍晓林,侯兆伟,杨勇,等.古龙1号乳液体系研制及性能评价[J].大庆石油地质与开发,2022,41(3):112-119.
WU Xiaolin,HOU Zhaowei,YANG Yong,et al.Development and performance evaluation for Gulong 1# emulsion system[J].Petroleum Geology & Oilfield Development in Daqing,2022,41(3):112-119.
[19] 刘俊凯,徐鑫,呼苏娟,等.沥青质沉积方式对储层渗透率的影响[J].大庆石油地质与开发,2023,42(2):91-98.
LIU Junkai,XU Xin,HU Sujuan,et al. Impact of asphaltene deposition patterns on reservoir permeability[J].Petroleum Geology & Oilfield Development in Daqing,2023,42(2):91-98.
[20] 高晓东,董平川,张友恒,等.井筒沥青质沉积位置预测方法[J].大庆石油地质与开发,2023,42(3):90-98.
GAO Xiaodong,DONG Pingchuan,ZHANG Youheng,et al. Prediction method for asphaltene deposition location in wellbore[J].Petroleum Geology & Oilfield Development in Daqing,2023,42(3):90-98.
[21] 袁斌,汪洋,白航航,等.CO2非混相驱原油膨胀及沥青质沉淀影响因素[J].大庆石油地质与开发,2023,42(4):105-112.
YUAN Bin,WANG Yang,BAI Hanghang,et al. Influencing factors of crude oil expansion and asphaltene precipitation in immiscible CO2 flooding[J].Petroleum Geology & Oilfield Development in Daqing,2023,42(4):105-112.
[22] 邸士莹,程时清,白文鹏,等.裂缝性致密油藏注水吞吐转不稳定水驱开发模拟[J].石油钻探技术,2022,50(1):89-96.
DI Shiying, CHENG Shiqing, BAI Wenpeng,et al.Simulation of transformation from water-injection huff and puff to unstable water-flooding in developing fractured tight reservoirs[J]. Petroleum Drilling Techniques,2022,50(1):89-96.
[23] 张志荣,陶国亮,SNOWDONLloyd R,等.沥青质大分子的结构及其测定方法综述[J].石油实验地质,2023,45(5):963-972.
ZHANG Zhirong,TAO Guoliang,SNOWDON Lloyd R,et al.Review on molecular structures of asphaltene macromolecules and instrumental analytical approaches[J].Petroleum Geology & Experiment,2023,45(5):963-972.
[24] 李二庭,靳军,陈亮,等.准噶尔盆地南缘井筒堵塞物中沥青质分子组成研究[J].石油实验地质,2022,44(2):306-313.
LI Erting,JIN Jun,CHEN Liang,et al.Molecular composition of asphaltene in wellbore blockage on the southern margin of Junggar Basin[J].Petroleum Geology & Experiment,2022,44(2):306-313.
[25] 张旭,张瑞,马若楠,等.纳米颗粒F-SiO2对地层原油中沥青质沉淀抑制效果[J].大庆石油地质与开发,2023,42(6):91-98.
ZHANG Xu,ZHANG Rui,MA Ruonan,et al.Inhibition effect of F-SiO2 nanoparticles on asphaltene precipitation in strata oil[J].Petroleum Geology & Oilfield Development in Daqing,2023,42(6):91-98.
Options
Outlines

/

〈 〉