To accurately predict the wellbore pressure,temperature,and sulfur precipitation patterns in high-sulfur gas reservoirs,based on the law of conservation of mass,momentum and energy,a predictive model for wellbore pressure,temperature,and sulfur precipitation in high-sulfur gas reservoirs was established with the comprehensive considerations of the influence of well deviation angle and gas-liquid-solid phase characteristics of sulfur;the finite difference method and iterative techniques model were used to solve the model;the compressibility factor algorithm was optimize based on field data;predictions of wellbore pressure,temperature,and sulfur precipitation trends were made after validating the accuracy of the model;and the influencing factors of wellbore pressure and sulfur precipitation patterns were studied.The results show that using the DPR algorithm for calculating the compressibility factor yields the smallest average relative errors in predicting wellbore pressure and temperature,at 0.93% and 1.06%,respectively.The fluid flow inside the wellbore is characterized as either single-phase gas or gas-solid two-phase flow,with no gas-liquid two-phase flow present.With the increase of gas production rates,H2S content,initial solubility of sulfur particles,and the decrease of well inclination,the variation range of wellbore pressure changes mounts gradually.Higher gas production rates result in sulfur precipitation closer to the wellhead with larger volumes of precipitated sulfur;higher H2S content leads to sulfur precipitation closer to the wellhead with smaller volumes of precipitated sulfur;larger initial solubilities of sulfur particles and greater well inclinations push the precipitation location further from the wellhead,resulting in larger volumes of precipitated sulfur.This research provides technical support for the efficient development of high-sulfur gas reservoirs.
[1] TANYS,LIHT,ZHOU X,et al.Inflow characteristics of horizontal wells in sulfur gas reservoirs-a comprehensive experimental investigation[J].Fuel,2019,239:267-274.
[2] FU L,HU J H,ZHANG Y,et al.Investigation on sulfur solubility in sour gas at elevated temperatures and pressures with an artificial neural network algorithm[J].Fuel,2020,262:1-10.
[3] 郭肖,陈亚丽,石建军,等.高含硫斜度井井筒硫沉积规律预测[J].大庆石油地质与开发,2021,40(1):74-80.
GUO Xiao,CHEN Yali,SHI Jianjun,et al.Prediction of the sulfur deposition law in the wellbore of high-sulfur deviated wells[J].Petroleum Geology and Oilfield Development in Daqing,2021,40(1):74-80.
[4] 吴晓东,吴晗,韩国庆,等.考虑井筒硫析出的高含硫气井井筒温度、压力场计算新模型[J].天然气工业,2011,31(9):69-72.
WU Xiaodong,WU Han,HAN Guoqing,et al.A new model for calculating wellbore temperature and pressure field of high-sulfur gas wells considering wellbore sulfur precipitation[J].Natural Gas Industry,2011,31(9):69-72.
[5] HU J H,HE S L,ZHAO J Z,et al.Modeling of sulfur plugging in a sour gas reservoir[J].Journal of Natural Gas Science and Engineering,2013,11:18-22.
[6] 刘成川,王本成.元坝气田超深层高含硫气井硫沉积预测[J].科学技术与工程,2020,20(6):2223-2230.
LIU Chengchuan,WANG Bencheng.Prediction of sulfur deposition in ultra-deep and high-sulfur gas well of Yuanba Gas Field[J].Science Technology and Engineering,2020,20(6):2223-2230.
[7] LIU Wenguan,HUANG Xin,ZHANG Le,et al.Analysis of sulfur deposition for high-sulfur gas reservoirs[J].Petroleum Science and Technology,2022,40(14):1716-1734.
[8] SUN F R,YAO Y D,LI X F.The heat and mass transfer characteristics of superheated steam coupled with non-condensing gases in horizontal wells with multi-point injection technique[J].Energy,2018,143:995-1005.
[9] ZHANG Y Y,LI P,SUN X F,et al.Steam conformance investigation of flow control devices deployed in SAGD injection and production horizontal wells[J].Journal of Petroleum Science and Engineering,2021,205:1-14.
[10] SUN F R,YAO Y D,CHEN M Q,et al.The flow and heat transfer characteristics of superheated steam in offshore wells and analysis of superheated steam performance[J].Energy,2017,125:795-804.
[11] HU J H,ZHAOJ Z,WANG L,et al.Prediction model of elemental sulfur solubility in sour gas mixtures[J].Journal of Natural Gas Science and Engineering,2014,18:31-38.
[12] SHAO M R,YANG Q,ZHOU B,et al.Effect of sulfur deposition on the horizontal well inflow profile in the heterogeneous sulfur gas reservoir[J].ACS Omega,2021,6:5009-5018.
[13] GU H,CHENG L S,HUANG S J,et al.Prediction of thermophysical properties of saturated steam and wellbore heat losses in concentric dual-tubing steam injection wells[J].Energy,2014,75:419-428.
[14] 罗红文,张琴,李海涛,等.基于分布式光纤测温的致密油水平井产出剖面解释方法[J].特种油气藏,2023,30(4):104-112.
LUO Hongwen,ZHANG Qin,LI Haitao,et al.Tight oil horizontal well production profile interpretation method based on distributed temperature sensing[J].Special Oil & Gas Reservoirs,2023,30(4):104-112.
[15] GUO X,WANG Q.A new prediction model of elemental sulfur solubility in sour gas mixtures[J].Journal of Natural Gas Science and Engineering,2016,31:98-108.
[16] QIN P X,LIU J Y.Modeling sulfur plugging of fractured wells under non-Darcy and non-equilibrium sulfur deposition[J].Journal of Geophysics and Engineering,2017,14:713-722.
[17] 吴亚军,王宁,张广东,等.高含硫气藏单质硫溶解度测试方法及预测模型[J].特种油气藏,2022,29(2):104-109.
WU Yajun,WANG Ning,ZHANG Guangdong,et al.Testing method and prediction model of elemental sulfur solubility in sour gas reservoirs[J].Special Oil & Gas Reservoirs,2022,29(2):104-109.
[18] CHRASTIL J.Solubility of solids and liquids in supercritical gases[J].The Journal of Physical Chemistry,1982,86(15):3016-3021.
[19] 赵欢,李玮,唐鹏飞,等.压裂工况下近井筒地应力及套管载荷分布规律研究[J].石油钻探技术,2023, 51(5):106-111.
ZHAO Huan, LI Wei, TANG Pengfei, et al.Study on the distribution law of near-wellbore in-situ stress and casing load under fracturing conditions[J].Petroleum Drilling Techniques,2023, 51(5):106-111.
[20] 赵向阳,赵聪,王鹏,等.超深井井筒温度数值模型与解析模型计算精度对比研究[J].石油钻探技术,2022, 50(4):69-75.
ZHAO Xiangyang, ZHAO Cong, WANG Peng, et al.A comparative study on the calculation accuracy of numerical and analytical models for wellbore temperature in ultra-deep wells[J].Petroleum Drilling Techniques,2022, 50(4):69-75.
[21] 任岚,蒋豪,赵金洲,等.考虑井筒变形的深层射孔井岩石破裂压力计算模型[J].大庆石油地质与开发,2022,41(6):64-73.
REN Lan,JIANG Hao,ZHAO Jinzhou,et al.Calculation model of breakdown pressure in deep perforated wells considering wellbore deformation[J].Petroleum Geology & Oilfield Development in Daqing,2022,41(6):64-73.
[22] 张小军,李军,张慧,等.天然裂缝分布对水力裂缝扩展及近井筒孔隙压力的影响[J].断块油气田,2022,29(6):831-836.
ZHANG Xiaojun,LI Jun,ZHANG Hui,et al.Influence of natural fracture distribution on hydraulic fracture extension and near wellbore pore pressure [J].Fault-Block Oil & Gas Field,2022,29(6):831-836.
[23] 高子康.存在硫析出的高含硫气井井筒压力计算方法研究[D].北京:中国地质大学(北京),2021.
GAO Zikang.Study on calculation method of wellbore pressure in high-sulfur gas wells with sulfur precipitation[D].Beijing:China University of Geosciences(Beijing),2021.
[24] 刘锦.高含硫气井井筒温度-压力预测[D].成都:西南石油大学,2017.
LIU Jin.Prediction of wellbore temperature and pressure in high sulfur gas wells[D].Chengdu:Southwest Petroleum University,2017.
