一种选择性堵水界面凝胶的研制

doi:10.3969/j.issn.1006-6535.2023.03.020

特种油气藏 ›› 2023, Vol. 30 ›› Issue (3): 155-160.DOI: 10.3969/j.issn.1006-6535.2023.03.020

一种选择性堵水界面凝胶的研制

李军^1,2, 王犁^2,3, 李勇¹, 陈启龙¹, 王莎¹, 鲁红升^2,3

1.中国石化西北油田分公司,新疆乌鲁木齐 842012;
2.西南石油大学,四川成都 610500;
3.油气田应用化学四川省重点实验室,四川成都 610500

收稿日期:2022-12-29 修回日期:2023-03-10 出版日期:2023-06-25 发布日期:2023-07-13
作者简介:李军(1983—),男,高级工程师,2006年毕业于成都理工大学资源勘查工程专业,现从事采油工程管理及科研工作。
基金资助:
国家自然科学基金“基于CO₂/N₂开关特性的O/W型稠油乳状液的构建和性能研究”(21403173);四川省杰出青年基金“面向含油废固处理技术的新型CO₂开关溶剂体系”(2019JDJQ0047);油气田应用化学四川省重点实验室开放基金“油诱导增稠型离子液体表面活性剂的制备及其作为非均相驱油剂的应用初探”(YQKF202112)

Development of Selective Water Plugging Interfacial Gel

Li Jun^1,2, Wang Li^2,3, Li Yong¹, Chen Qilong¹, Wang Sha¹, Lu Hongsheng^2,3

1. Sinopec Northwest Oilfield Company, Urumqi, Xinjiang 842012, China;
2. Southwest Petroleum University, Chengdu, Sichuan 610500, China;
3. Oil & Gas Field Applied Chemistry Key Laboratory of Sichuan Province, Chengdu, Sichuan 610500, China

Received:2022-12-29 Revised:2023-03-10 Online:2023-06-25 Published:2023-07-13

摘要/Abstract

摘要： 针对高分子聚合物选择性堵水凝胶油水选择性差、注入压力大等缺点,利用N,N-二甲基环己胺分别与硬脂酸、花生酸、山嵛酸,通过酸胺中和反应合成小分子凝胶因子,该小分子凝胶因子能够在油水界面上自发形成界面凝胶。利用偏光显微镜及流变仪探究了界面凝胶的微观形貌以及流变学性能,利用驱替实验考察了小分子凝胶因子在油水界面的选择性堵水性能。结果表明:小分子凝胶因子在油水界面形成的界面凝胶的黏度可达105 mPa·s以上,屈服应力高达100 Pa;驱替实验证明,小分子凝胶因子能够选择性封堵水通道,突破压力梯度达到2.74 MPa/m,采收率提高了21.3个百分点。该小分子凝胶因子具有良好的油水选择性,能够有效提高原油采收率,具有推广应用价值。

关键词: 选择性堵水, 小分子凝胶因子, 界面凝胶, 脂肪酸

Abstract: In response to the disadvantages of poor oil-water selectivity and high injection pressure of high polymer selective water plugging gels, small-molecule gel factors were synthesized through the acid-amine neutralization reaction between N,N-dimethylcyclohexylamine and stearic acid, arachidic acid and behenic acid respectively, which can spontaneously form interfacial gels at the oil-water interface. The microscopic appearance and rheological properties of the interfacial gels were investigated by polarizing microscope and rheometer, and the selective water plugging performance of the small-molecule gel factor at the oil-water interface was investigated by displacement experiments. The results show that the viscosity of the interfacial gel formed by the small-molecule gel factor at the oil-water interface can reach 105 mPa·s or more, and the yield stress is as high as 100 Pa; the displacement experiment proves that the small-molecule gel factor can selectively block the water channel, the breakthrough pressure gradient is up to 2.74 MPa/m, and the recovery rate is enhanced by 21.3 percentage points. The small-molecule gel factor has good oil-water selectivity and can effectively enhance the recovery of crude oil, so it is worth to be promoted and applied.

Key words: selective water plugging, small-molecule gel factor, interfacial gel, fatty acid

中图分类号:

TE39

李军, 王犁, 李勇, 陈启龙, 王莎, 鲁红升. 一种选择性堵水界面凝胶的研制[J]. 特种油气藏, 2023, 30(3): 155-160.

Li Jun, Wang Li, Li Yong, Chen Qilong, Wang Sha, Lu Hongsheng. Development of Selective Water Plugging Interfacial Gel[J]. Special Oil & Gas Reservoirs, 2023, 30(3): 155-160.

参考文献

[1] 纪朝凤,葛红江.调剖堵水材料研究现状与发展趋势[J].石油钻采工艺,2002,24(1):54-57.
JI Chaofeng,GE Hongjiang.Recent study and development of material for profile control and water shutoff[J].Oil Drilling & Production Technology,2002,24(1):54-57.
[2] 蒲万芬,胡书宝,陈刚,等.XN-PP调剖堵水体系的研究及性能评价[J].钻井液与完井液,1997,14(5):5-9.
PU Wanfen,HU Shubao,CHEN Gang,et al.Evaluation of water shutoff system XN-PP[J].Drilling Fluid & Completion Fluid,1997,14(5):5-9.
[3] 李宜坤,覃和,蔡磊.国内堵水调剖的现状及发展趋势[J].钻采工艺,2006,29(5):105-106.
LI Yikun,QIN He,CAI Lei.Current situation and development direction of water shutoff & profile control in China[J].Drilling & Production Technology,2006,29(5):105-106.
[4] 李延军,彭珏,赵连玉,等.低渗透油层物理化学采油技术综述[J].特种油气藏,2008,15(4):7-12.
LI Yanjun,PENG Jue,ZHAO Lianyu,et al.An overview of physical and chemical oil recovery techniques for low permeability reservoirs[J].Special Oil & Gas Reservoirs,2008,15(4):7-12.
[5] 向辉,冯宁,职文栋,等.低渗透油藏注表面活性剂提高采收率技术研究及应用[J].化学工程师,2022,36(5):42-45.
XIANG Hui,FENG Ning,ZHI Wendong,et al.Research and application of surfactant injection to enhance oil recovery in low permeability reservoir[J].Chemical Engineer,2022,36(5):42-45.
[6] 陈辉,曲典,吴胜.油田化学堵水工艺技术探析[J].石化技术,2019,26(6):49-50.
CHEN Hui,QU Dian,WU Sheng.Exploration and analysis of chemical water plugging technology in oilfield[J].Petrochemical Industry Technology,2019,26(6):49-50.
[7] 唐佳斌,李悦欣,肖路业,等.化学调剖堵水剂研究现状[J].应用化工,2022,51(2):587-591.
TANG Jiabin,LI Yuexin,XIAO Luye,et al.Research status of chemical profile control and water plugging agents[J].Applied Chemical Industry,2022,51(2):587-591.
[8] 姚荣华.L油田特高含水期开发效果评价及开发对策研究[D].东营:中国石油大学(华东),2017.
YAO Ronghua.Evaluation of development effect and research on development countermeasures in special high water cut period of L Oilfield[D].Dongying:China University of Petroleum(East China),2017.
[9] 赵福麟.油井选择性堵水[J].中国石油大学学报(自然科学版),2010,34(1):84-92.
ZHAO Fulin.Selective water shutoff for oil well[J].Journal of China University of Petroleum(Edition of Natural Sciences),2010,34(1):84-92.
[10] 刘怀珠,李良川,郑家朋,等.水平井选择性化学堵水技术在冀东油田浅层边底水油藏的研究与应用[J].石油地质与工程,2010,24(2):109-111.
LIU Huaizhu,LI Liangchuan,ZHENG Jiapeng,et al.Study and application of chemical plugging in horizontal wells of edge/bottom water reservoir in Jidong Oilfield[J].Petroleum Geology & Engineering,2010,24(2):109-111.
[11] 贾虎,蒲万芬.有机凝胶控水及堵水技术研究[J].西南石油大学学报(自然科学版),2013,35(6):141-152.
JIA Hu,PU Wanfen.Research on water control and water shutoff technologies of organic-gel[J].Journal of Southwest Petroleum University(Science & Technology Edition),2013,35(6):141-152.
[12] 宋昭峥,张建存,李宜坤.溶液型选择性堵水剂的研究现状[J].化工科技,2010,18(4):63-66.
SONG Zhaozheng,ZHANG Jiancun,LI Yikun.Development of relative permeability modifier[J].Science Technology in Chemical Industry,2010,18(4):63-66.
[13] 张永忠,贾晓菊,邱家友,等.油井化学堵水技术在延长组油层应用与评价[J].石油化工应用,2016,35(3):41-43.
ZHANG Yongzhong,JIA Xiaoju,QIU Jiayou,et al.Application and evaluation of chemical water plugging technology for oil wells in Yanchang Formation[J].Petrochemical Industry Application,2016,35(3):41-43.
[14] 李志臻,史斌,麻路,等.一种溶液型选择性堵水体系的室内研究及应用[J].石油化工应用,2020,39(1):53-61.
LI Zhizhen,SHI Bin,MA Lu,et al.Research and application of a solution type water shutoff system[J].Petrochemical Industry Application,2020,39(1):53-61.
[15] 李虎,王晓龙,徐国瑞,等.一种低分子选择性堵水剂实验研究[J].辽宁化工,2021,50(4):477-479.
LI Hu,WANG Xiaolong,XU Guorui,et al.Experimental study on a low molecular weight selective water plugging agent[J].Liaoning Chemical Industry,2021,50(4):477-479.
[16] CLARKE C J,TU W C,LEVERS O,et al.Green and sustainable solvents in chemical processes[J].Chemical Reviews,2018,118(2):747-800.
[17] LI C H,HE J H,LIU J H,et al.Self-assembly of lyotropic liquid crystal phases in ternary systems of 1,2-dimethyl-3-hexadecylimidazolium bromide/1-decanol/water[J].Journal of Colloid and Interface Science,2010,342(2):354-360.
[18] TORRES M D,CORCHERO R,RODRIGUEZ-ESCONTRELA I,et al.Thermo-rheology of a proline-based surface-active ionic liquid:mixtures with water and n-octane[J].Chemical Engineering & Technology,2019,42(9):1952-1959.
[19] LI Q T,TONG K,SUN M,et al.The self-assembly of an imidazolium surfactant in an aprotic ionic liquid.1.comparison in aprotic and protic ionic liquids [J].Soft Matter,2020,16(31):7246-7249.
[20] GOOSSENS K,LAVA K,BIELAWSKI C W,et al.Ionic liquid crystals:versatile materials[J].Chemical Reviews,2016,116(8):4643-480.
[21] 王涛.华北油田某区块选择性堵水剂优选及评价[D].北京:中国石油大学(北京),2020.
WANG Tao.Optimal selection and evaluation of selective water plugging agent in a block of Huabei Oilfield[D].Beijing:China University of Petroleum (Beijing),2020.

一种选择性堵水界面凝胶的研制

Development of Selective Water Plugging Interfacial Gel

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 5

编辑推荐

Metrics

本文评价

[1]	陈　渊. 正负电性聚合物选择性控水技术[J]. 特种油气藏, 2014, 21(5): 123-.
[2]	张锋利,郑春峰,刘跃忠,刘艳涛,李芳. 中心管采油技术在水平井开发底水油藏中的应用[J]. 特种油气藏, 2013, 20(4): 144-146.
[3]	肖立新. 低渗裂缝性高凝稠油油藏油井选择性堵水技术[J]. , 2012, 19(2): 1-.
[4]	李金权. 改性石蜡选择性堵水技术研究与现场应用[J]. , 2007, 14(4): 1-.
[5]	陈大钧　黄辉远　黎真. 渗透性微细水泥堵水技术研究[J]. , 2005, 12(6): 1-.