体积压裂改造非对称性对套管损坏影响机理

林志伟; 钟守明; 宋琳; 王雪刚; 林铁军; 于浩; 史涛

doi:10.3969/j.issn.1006-6535.2021.06.021

特种油气藏 >

2021 , Vol. 28 >Issue 6: 158 - 164

DOI: https://doi.org/10.3969/j.issn.1006-6535.2021.06.021

钻采工程

体积压裂改造非对称性对套管损坏影响机理

林志伟 ,
钟守明 ,
宋琳 ,
王雪刚 ,
林铁军 ,
于浩 ,
史涛

展开

1.中国石油新疆油田分公司,新疆克拉玛依 834000;
2.西南石油大学油气藏地质及开发工程国家重点实验室,四川成都 610500;
3.新疆润霖新能源技术有限公司,新疆克拉玛依 834000

林志伟(1992—),男,助理工程师,2015年毕业于中国石油大学(华东)工程力学专业,2018年毕业于该校油气井工程专业,获硕士学位,现从事固井工艺技术研究工作。

收稿日期: 2020-12-22

修回日期: 2021-09-25

网络出版日期: 2022-02-16

基金资助

新疆科技厅支疆项目“新疆油田复杂工况环境油井管力学损伤理论及安全评价研究与应用”(2021E02043);四川省科技厅中央引导地方项目“页岩气井裂隙岩体多场耦合蠕变规律及井筒完整性研究”(2020ZYD052)

收起

Study on the Mechanism of the Asymmetry Effect of SRV Fracturing on Casing Damage

Lin Zhiwei ,
Zhong Shouming ,
Song Lin ,
Wang Xuegang ,
Lin Tiejun ,
Yu Hao ,
Shi Tao

Expand

1. PetroChina Xinjiang Oilfield Company, Karamay, Xinjiang 834000, China;
2. State Key Laboratory of Oil and Gas Reservoir Geology and Exploration, Southwest Petroleum University, Chengdu, Sichuan 610500, China;
3. Xinjiang Runlin New Energy Technology Co., Ltd., Karamay, Xinjiang 834000, China

Received date: 2020-12-22

Revised date: 2021-09-25

Online published: 2022-02-16

Fold

摘要

针对致密油气藏体积压裂改造过程中的套管损坏问题,根据弹塑性力学、接触力学理论,结合体积压裂改造施工实际情况,建立全三维尺寸的套管-水泥环-地层耦合有限元分析模型,以不同椭圆柱形表征体积压裂改造的非对称区域,采用Fortran子程序对ABAQUS求解器进行干预和二次开发,模拟了体积压裂改造区域水化膨胀的物性动态演化和力学性质。结果表明:随着椭圆形改造区域长短轴之比增加,井筒周围外载荷的非均匀性增强,通过水泥环传递到套管上的非均匀程度先增加后趋于稳定;随体积膨胀率增加,套管外载荷的非均匀程度增加;套管外载荷非均匀性的增强极大地增加了套管的应力水平,容易造成套管失效问题。该研究可为体积压裂参数优化设计提供理论依据,对预防套管及水泥环失效具有指导意义。

关键词： 体积压裂; 非对称性; 套管损坏; 有限元分析; 应力变化; 致密油气藏

本文引用格式

林志伟 , 钟守明 , 宋琳 , 王雪刚 , 林铁军 , 于浩 , 史涛 . 体积压裂改造非对称性对套管损坏影响机理[J]. 特种油气藏, 2021 , 28(6) : 158 -164 . DOI: 10.3969/j.issn.1006-6535.2021.06.021

Abstract

To address the problem of casing damage in the SRV fracturing of tight oil and gas reservoirs, a full-sized three-dimensional casing-cement sheath-formation coupled finite element analysis model was established according to the theories of elastoplastic mechanics and contact mechanics and the actual construction conditions of SRV fracturing, with SRV fracturing asymmetric zones characterized by different elliptic cylinders and ABAQUS solver intervened and secondly developed with Fortran subroutine, in order to simulate the dynamic evolution of physical properties and the analysis of mechanical properties of hydration-induced swelling in the SRV fracturing zones. The results showed that the loads outsides the perimeter of the wellbore were more nonuniform with the increase of the ratio of the long and short axes in the elliptical stimulated zone, and the non-uniformity transmitted to the casing through the cement sheath increased first and then tended to be stable; the non-uniformity of the external load on the casing increased with the increase of the volume expansion rate; the increase of the non-uniformity of the external load on the casing exerted more stress on the casing, easily leading to casing failure. This study provides a theoretical basis for the optimal design of SRV fracturing parameters, and plays a guiding role in the prevention against casing and cement sheath failure.

Key words： SRV fracturing; asymmetry; casing damage; finite element analysis; stress change; tight oil and gas reservoir

参考文献

[1] 殷有泉,李平恩.非均匀载荷下套管强度的计算[J].石油学报, 2007, 28(6): 138-141,146.
YIN Youquan,LI Ping′en.Computation of casing strength under non-uniform load[J].Acta Petrolei Sinica,2007,28(6):138-141,146.
[2] 殷有泉,蔡永恩,陈朝伟,等.非均匀地应力场中套管载荷的理论解[J].石油学报, 2006,27(4): 133-138.
YIN Youquan,CAI Yong′en,CHEN Chaowei,et al.Theoretical solution of casing loading in non-uniform ground stress field[J].Acta Petrolei Sinica,2006,27(4):133-138.
[3] 李平恩,殷有泉,苏先樾.流变地层地应力场中套管载荷的理论解[J].北京大学学报(自然科学版),2007, 43(1): 11-16.
LI Ping′en,YIN Youquan,SU Xianyue.Theoretical solution of casing loads in rheological formation in tectonic stress field[J].Acta Scientiarum Naturalium Universitatis Pekinensis,2007,43(1):11-16.
[4] PATTILLO P D,LAST N C,ASBILL W T.Effect of nonuniform stressing on conventional casing collapse resistance[C].SPE79871,2004:1-10.
[5] 于浩,练章华,林铁军.页岩气压裂过程套管失效机理有限元分析[J].石油机械, 2014, 42(8): 84-88, 93.
YU Hao,LIAN Zhanghua,LIN Tiejun.Finite element analysis of failure mechanism of casing during shale gas fracturing[J].China Petroleum Machinery,2014,42(8):84-88,93.
[6] 于浩,练章华,林铁军,等.页岩气体积压裂过程中套管失效机理研究[J].中国安全生产科学技术, 2016, 12(10): 37-43.
YU Hao,LIAN Zhanghua,LIN Tiejun,et al.Study on failure mechanism of casing in stimulated reservoir volume fracturing of shale gas[J].Journal of Safety Science and Technology,2016,12(10):37-43.
[7] LIAN Z H,YU H,LIN T J,et al.A study on casing deformation failure during multi-stage hydraulic fracturing for the stimulated reservoir volume of horizontal shale wells[J].Journal of Natural Gas Science and Engineering,2015,23(3):538-546.
[8] 刘奎,高德利,王宴滨,等.局部载荷对页岩气井套管变形的影响[J].天然气工业, 2016, 36(11): 76-82.
LIU Kui,GAO Deli,WANG Yanbin,et al.Effects of local load on shale gas well casing deformation[J].Natural Gas Industry,2016,36(11):76-82.
[9] GUO Y,LAST N,BLANFORD M.Simple calculation of compaction-induced casing deformation adjacent to reservoir boundaries[C].SPE189694,2018:1-18.
[10] 陈朝伟,石林,项德贵.长宁-威远页岩气示范区套管变形机理及对策[J].天然气工业, 2016, 36(11): 70-75.
CHEN Chaowei,SHI Lin,XIANG Degui.Mechanism of casing deformation in the Changning-Weiyuan national shale gas project demonstration area and countermeasures[J].Natural Gas Industry,2016,36(11):70-75.
[11] 陈朝伟,王鹏飞,项德贵.基于震源机制关系的长宁-威远区块套管变形分析[J].石油钻探技术, 2017, 45(4): 110-114.
CHEN Chaowei,WANG Pengfei,XIANG Degui.Analysis of casing deformation in the Changning-Weiyuan Block based on focal mechanism[J].Petroleum Drilling Techniques,2017,45(4):110-114.
[12] 田中兰,石林,乔磊.页岩气水平井井筒完整性问题及对策[J].天然气工业, 2015, 35(9): 70-76.
TIAN Zhonglan,SHI Lin,QIAO Lei.Research of and countermeasure for wellbore integrity of shale gas horizontal well[J].Natural Gas Industry,2015,35(9):70-76.
[13] 乔磊,田中兰,曾波,等.页岩气水平井多因素耦合套变分析[J].断块油气田, 2019, 26(1): 107-110.
QIAO Lei,TIAN Zhonglan,ZENG Bo,et al.Multi-factor coupling casing deformation for shale horizontal wells[J].Fault-Block Oil & Gas Field,2019,26(1):107-110.
[14] 郭雪利,李军,柳贡慧,等.基于震源机制的页岩气压裂井套管变形机理[J].断块油气田, 2018, 25(5): 665-669.
GUO Xueli,LI Jun,LIU Gonghui,et al.Research on casing deformation for shale gas wells based on focal mechanism[J].Fault-Block Oil & Gas Field,2018,25(5):665-669.
[15] 李军,李玉梅,张德龙,等.页岩气井分段压裂套损影响因素分析[J].断块油气田, 2017, 24(3): 387-390.
LI Jun,LI Yumei,ZHANG Delong,et al.Analysis of casing damage for staged fracturing in shale gas well[J].Fault-Block Oil & Gas Field,2017,24(3):387-390.
[16] 席岩,柳贡慧,李军,等.页岩气井体积压裂井筒温度计算及套管强度变化分析[J].断块油气田, 2017, 24(4): 561-564.
XI Yan,LIU Gonghui,LI Jun,et al.Calculation of wellbore temperature and analysis of its effect on casing strength during volume fracturing in shale gas well[J].Fault-Block Oil & Gas Field,2017,24(4):561-564.
[17] 席岩,李军,柳贡慧,等.瞬态力-热耦合作用下水泥环形态对套管应力的影响[J].断块油气田, 2017, 24(5): 700-704.
XI Yan,LI Jun, LIU Gonghui,et al.Impact analysis of cement sheath shape on casing stress under transient mechanical-thermal coupling effect[J].Fault-Block Oil & Gas Field,2017,24(5):700-704.
[18] WU X Y,HAN L H,YANG S Y,et al.Numerical study on casing integrity during hydraulic fracturing shale formation[C].SPE195203,2019:1-12.
[19] 张智,刘金铭,刘和兴,等.页岩气井压裂过程中套管损坏的机理[J].天然气工业, 2019, 39(10): 82-87.
ZHANG Zhi,LIU Jinming,LIU Hexing,et al.Mechanisms of casing damage during shale gas well fracturing treatment[J].Natural Gas Industry,2019,39(10):82-87.
[20] 李文哲,文乾彬,肖新宇,等.页岩气长水平井套管安全下入风险评估技术[J].天然气工业, 2020, 40(9): 97-104.
LI Wenzhe,WEN Qianbin,XIAO Xinyu,et al.Risk evaluation technology for safe casing running in long horizontal shale gas wells[J].Natural Gas Industry,2020,40(9):97-104.
[21] 杨同玉,韩峰,马兰荣.尾管固井回接压裂套管屈曲失效研究[J].断块油气田,2019,26(5):666-669.
YANG Tongyu,HAN Feng,MA Lanrong.Casing buckling failure analysis in tie-back fracturing under liner cementing conditions[J].Fault-Block Oil & Gas Field,2019,26(5):666-669.
[22] 赵春艳,王波,罗垚,等.页岩油套管变形水平井暂堵分段压裂工艺[J].断块油气田,2020,27(6):715-718.
ZHAO Chunyan,WANG Bo,LUO Yao,et al.Temporary plugging and staged fracturing technology for casing deformation section in horizontal shale oil wells[J].Fault-Block Oil & Gas Field,2020,27(6):715-718.
[23] 许寻,李中超,刘广英,等.深层高压低渗透砂岩油藏储层应力敏感性模型及开发指标变化规律——以文东油田为例[J].油气地质与采收率,2020,27(6):122-129.
XU Xun,LI Zhongchao,LIU Guangying,etal.Stress sensitivitymodel and development index trend in deep high-pressure and low-permeability sandstone reservoirs:a case study of Wendong Oilfield[J].Petroleum Geology and Recovery Efficiency,2020,27(6):122-129.
[24] 吴双,汤达祯,李松,等.煤层气储层孔渗参数的应力响应特征[J].油气地质与采收率,2019,26(6):80-86.
WU Shuang,TANG Dazhen,LI Song,et al.Stress response characteristics of porosity and permeability of coalbed methane reservoirs[J].Petroleum Geology and Recovery Efficiency,2019,26(6):80-86.
[25] 汤勇,刘琦.低渗透应力敏感性油藏的合理开发[J].油气地质与采收率,2017,24(4):105-109.
TANG Yong,LIU Qi.Rational exploitation in low permeability oil reservoir with stress sensitivity[J].Petroleum Geology and Recovery Efficiency,2017,24(4):105-109.
[26] 郑永香,刘建军. 注水条件下近裂缝带的地应力演化规律[J].大庆石油地质与开发,2020,39(1):62-73.
ZHENG Yongxiang,LIU Jianjun. Earth-stress evolution law near the fracture belt under the condition of the water injection[J].Petroleum Geology & Oilfield Development in Daqing,2020,39(1):62-73.
[27] 唐巨鹏,齐桐,路江伟. 考虑吸附膨胀和滤失附加应力的井壁应力模型[J].大庆石油地质与开发,2020,39(1):144-152.
TANG Jupeng, QI Tong, LU Jiangwei. Well wall stress model considering the adsorption expansion andfiltration additional stress[J].Petroleum Geology & Oilfield Development in Daqing,2020,39(1):144-152.
[28] 张金才,亓原昌.地应力对页岩储层开发的影响与对策[J].石油与天然气地质,2020,41(4):766-783.
ZHANG Jincai,QI Yuanchang.Impact of in-situ stresses on shale reservoir development and its countermeasures[J].Oil & Gas Geology,2020,41(4):766-783.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献