低渗透稠油微波原位加热开采数值模拟研究

李小刚; 朱静怡; 杨兆中; 谢诗意; 贾敏

doi:10.3969/j.issn.1006-6535.2020.06.017

特种油气藏 >

2020 , Vol. 27 >Issue 6: 120 - 126

DOI: https://doi.org/10.3969/j.issn.1006-6535.2020.06.017

油藏工程

低渗透稠油微波原位加热开采数值模拟研究

李小刚 ,
朱静怡 ,
杨兆中 ,
谢诗意 ,
贾敏

展开

1.西南石油大学油气藏地质及开发工程国家重点实验室,四川成都 610500;
2.西南石油大学化学化工学院,四川成都 610500

李小刚(1981—),男,教授,2003年毕业于西南石油学院石油工程专业,2009年毕业于西南石油大学油气田开发工程专业,获博士学位,现从事油气增产改造理论、技术和非常规天然气开发研究工作。

收稿日期: 2020-06-10

修回日期: 2020-08-27

网络出版日期: 2022-02-18

基金资助

国家科技重大专项“多层复杂煤体结构区煤储层直井压裂技术研究”(2016ZX044-004-002);西南石油大学“启航计划”基金“纳米材料辅助微波加热条件下油页岩热解规律研究”(2015QHZ006)

收起

Numerical Simulation Research on Microwave In-situ Heating Technology for Developing Heavy Oil in Low-permeability Reservoirs

Li Xiaogang ,
Zhu Jingyi ,
Yang Zhaozhong ,
Xie Shiyi ,
Jia Min

Expand

1. State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Chengdu, Sichuan 610500, China;
2. College of Chemistry and Chemical Engineering, Southwest Petroleum University, Chengdu, Sichuan 610500, China

Received date: 2020-06-10

Revised date: 2020-08-27

Online published: 2022-02-18

Fold

摘要

针对低渗透稠油油藏开采过程中储层注入能力低、热损失高、水资源消耗大等问题,采用数值模拟对微波加热稠油开采技术进行研究,通过建立电磁-传热-流动多物理场模型,明确了微波加热稠油的降黏作用和传热机理。研究结果表明:稠油油藏微波加热后可分为电磁穿透区、多孔介质传导区和未加热区3个区域;最佳辐射频率为2 450 MHz,增加功率可快速提高地层温度;为了避免井筒附近出现过热现象,应采用降功率的阶梯式加热模式;水力压裂裂缝可有效改善低渗透油藏的渗流通道,可与微波加热协同开采稠油油藏。该研究可为低渗透及高黏度稠油的开发提供借鉴。

关键词： 低渗稠油油藏; 微波加热; 数值模拟; 多物理场; 水力压裂裂缝; 开采机理; 影响因素

本文引用格式

李小刚 , 朱静怡 , 杨兆中 , 谢诗意 , 贾敏 . 低渗透稠油微波原位加热开采数值模拟研究[J]. 特种油气藏, 2020 , 27(6) : 120 -126 . DOI: 10.3969/j.issn.1006-6535.2020.06.017

Abstract

In the exploitation of low-permeability heavy oil reservoirs, aiming at the problems such as low reservoir injection capacity, high heat loss, and large water consumption, etc., numerical simulation technique was used to study the microwave heating technology for developing heavy oil. Through establishing multiple physical field models such as electromagnetic field model, heat transfer field model, and flow field model, the heavy oil viscosity reduction effect and heat transfer mechanism of microwave radiation was clarified. The research results show that after microwave heating, heavy oil reservoirs can be divided into three zones, namely electromagnetic penetration zone, conduction zone in porous media and unheated zone; the best radiation frequency is 2 450 MHz, and increasing power can quickly increase the formation temperature; in order to avoid overheating around the wellbore, a stepped heating mode with gradual power reduction should be adopted; hydraulic fractures can effectively improve the seepage channels of low-permeability reservoirs, and it can be used in conjunction with microwave heating to develop heavy oil reservoirs. This research can provide a reference for developing low-permeability and high-viscosity heavy oil.

Key words： low-permeability heavy oil reservoir; microwave heating; numerical simulation; multiple physical field; hydraulic fracture; exploitation mechanism; influencing factor

参考文献

[1] 赵修太,付敏杰,王增宝,等.稠油热采调堵体系研究进展综述[J].特种油气藏,2013,20(4):1-4.
ZHAO Xiutai,FU Minjie,WANG Zengbao,et al.Research overview of profile control and water shut-off agents for heavy oil thermal recovery[J].Special Oil & Gas Reservoirs,2013,20(4):1-4.
[2] 刘尚奇,王晓春,高永荣,等.超稠油油藏直井与水平井组合SAGD技术研究[J].石油勘探与开发,2007,34(2):234-238.
LIU Shangqi,WANG Xiaochun,GAO Yongrong,et al.SAGD process with the combination of vertical and horizontal wells in super-heavy oil reservoir[J].Petroleum Exploration and Development,2007,34(2):234-238.
[3] 魏超平.薄层稠油蒸汽驱数值模拟研究[J].特种油气藏,2016,23(4):115-118.
WEI Chaoping.Numerical simulation of steam flooding in thin heavy oil reservoir[J].Special Oil & Gas Reservoirs,2016,23(4):115-118.
[4] 张起豪,熊攀,丁鲁振.微波辐射稠油降黏机理的研究进展[J].广东化工,2013,40(15):76-77.
ZHANG Qihao,XIONG Pan,DING Luzhen.Research progress of the mechanism on viscosity reduction of the heavy oil radiated by the microwave[J].Guangdong Chemical Industry,2013,40(15):76-77.
[5] LI K W,HOU B C,WANG L,et al.Application of carbon nanocatalysts in upgrading heavy crude oil assisted with microwave heating[J].Nano Letters,2014,14(6):3002-3008.
[6] WANG Z,GAO D,FANG J.Numerical simulation of RF heating heavy oil reservoir based on the coupling between electromagnetic and temperature field[J].Fuel,2018,220:14-24.
[7] MUTYALA S,FAIRBRIDGE C, PARéJR J,et al.Microwave applications to oil sands and petroleum:a review[J].Fuel Processing Technology,2010,91(2):127-135.
[8] 杨兆中,朱静怡,李小刚,等.微波辐射用于处理和开采岩石的研究进展[J].科学技术与工程,2019,19(5):1-7.
YANG Zhaozhong,ZHU Jingyi,LI Xiaogang,et al.Progress in researches on microwave irradiation on rocks for treatment and exploitation[J].Science Technology and Engineering,2019,19(5):1-7.
[9] LI H,LIN B Q,YANG W,et al.A fully coupled electromagnetic-thermal-mechanical model for coalbed methane extraction with microwave heating[J].Journal of Natural Gas Science and Engineering,2017,46:830-844.
[10] SRESTY G C,DEV H,SNOW R H,et al.Recovery of bitumen from tar sand deposits with the radio frequency process[J].SPE Reservoir Engineering,1986,1(1):85-94.
[11] 汪双清,沈斌,孙玮琳.微波辐射对稠油化学组成的影响[J].特种油气藏,2011,18(1):109-112.
WANG Shuangqing,SHEN Bin,SUN Weilin.The impact of microwave radiation on chemical composition of heavy oil[J].Special Oil & Gas Reservoirs,2011,18(1):109-112.
[12] 熊攀.微波频率对稠油降黏效果影响的实验研究[D].西安:西安石油大学,2014.
XIONG Pan.The experimental study of heavy crude oil viscosity reduction effect by microwave[D].Xi′an:Xi′an Shiyou University,2014.
[13] SAHNI A,KUMAR M,KNAPP R B.Electromagnetic heating methods for heavy oil reservoirs[C].SPE62550,2000:1-10.
[14] PITCHAI K,BIRLA S L,SUBBIAH J,et al.Coupled electromagnetic and heat transfer model for microwave heating in domestic ovens[J].Journal of Food Engineering,2012,112(1/2):100-111.
[15] BOGDANOV I,TORRES J,CORRE B.Numerical simulation of electromagnetic driven heavy oil recovery[C].SPE154140,2012:1-17.
[16] 左小军,袁文芳,何巧林,等.基于岩石热解和荧光显微图像分析的储层流体性质划分及应用——以轮南2油田JIV油组为例[J].东北石油大学学报,2017,41(2):94-102.
ZUO Xiaojun,YUAN Wenfang,HE Qiaolin,et al.Division and application of multi method reservoir fluid properties based on rock pyrolysis and fluorescence image analysis:a case study of oil measure-JIV of wellblock No.2 of Lunnan Oilfield[J].Journal of Northeast Petroleum University,2017,41(2):94-102.
[17] 葛涛涛,庞占喜,罗成栋,等.海上稠油油藏水平井多元热流体驱物理模拟实验研究[J].油气地质与采收率,2019,26(4):62-69.
GE Taotao,PANG Zhanxi,LUO Chengdong,et al.Experimental study on multi-thermal fluid flooding by using horizontal wells in offshore heavy oil reservoirs[J].Petroleum Geology and Recovery Efficiency,2019,26(4):62-69.
[18] 卢聪,卢云霄,李芝力,等.柱状支撑裂缝内流体流动规律[J].油气地质与采收率,2019,26(4):111-118.
LU Cong,LU Yunxiao,LI Zhili,et al.Fluid flow pattern in fractures supported by proppant pillars[J].Petroleum Geology and Recovery Efficiency,2019,26(4):111-118.
[19] 惠威,贾昱昕,程凡,等.苏里格气田东部盒₈储层微观孔隙结构及可动流体饱和度影响因素[J].油气地质与采收率,2018,25(5):10-16.
HUI Wei,JIA Yuxin,CHENG Fan,et al.Impact of microscopic pore structure on moveable fluid saturation in He₈ reservoir of eastern Sulige Gasfield[J].Petroleum Geology and Recovery Efficiency,2018,25(5):10-16.
[20] 彭娇,曲冠政,卫海涛,等.基于裂缝中流体渗流特征的迂曲度计算新方法[J].断块油气田,2019,26(4):495-500.
PENG Jiao,QU Guanzheng,WEI Haitao,et al.New tortuosity calculation based on fluid migration characteristics in fracture[J].Fault-Block Oil & Gas Field,2019,26(4):495-500.
[21] 刘勇,王崇先,李晓辉,等.深层超稠油多元热流体开采机理[J].断块油气田,2019,26(5):638-643.
LIU Yong,WANG Chongxian,LI Xiaohui,et al.Development mechanism of multivariate thermal fluid of deep super-heavy oil[J].Fault-Block Oil & Gas Field,2019,26(5):638-643.
[22] 黎盼,孙卫,闫健,等.鄂尔多斯盆地马岭油田长₈¹储层不同流动单元可动流体赋存特征及其影响因素[J].石油实验地质,2018,40(3):362-371.
LI Pan,SUN Wei,YAN Jian,et al.Characteristics of movable fluids and controlling factors in different flow units of Chang₈¹ reservoir in Maling Oilfield,Ordos Basin[J].Petroleum Geology & Experiment,2018,40(3):362-371.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献