低渗透油藏空气驱原油氧化机理实验

滕卫卫; 吴庆祥; 胡晓蝶; 王晓光; 程宏杰; 朱桂芳

doi:10.3969/j.issn.1006-6535.2022.03.015

特种油气藏 >

2022 , Vol. 29 >Issue 3: 104 - 111

DOI: https://doi.org/10.3969/j.issn.1006-6535.2022.03.015

油藏工程

低渗透油藏空气驱原油氧化机理实验

滕卫卫 ,
吴庆祥 ,
胡晓蝶 ,
王晓光 ,
程宏杰 ,
朱桂芳

展开

中国石油新疆油田分公司,新疆克拉玛依 834000

滕卫卫(1978—),男,高级工程师,2002年毕业于石油大学(华东)石油工程专业,现主要从事非常规油气提高采收率研究工作。

收稿日期: 2021-09-09

修回日期: 2022-03-15

网络出版日期: 2023-01-09

基金资助

中国石油重大科技项目“‘二三结合’协同提高采收率关键技术研究”(kt2021-07-03)

收起

Experiment on Oxidation Mechanism of Crude Oil by Air Flooding in Low permeability Reservoirs

Teng Weiwei ,
Wu Qingxiang ,
Hu Xiaodie ,
Wang Xiaoguang ,
Cheng Hongjie ,
Zhu Guifang

Expand

PetroChina Xinjiang Oilfield Company, Karamay, Xinjiang 834000, China

Received date: 2021-09-09

Revised date: 2022-03-15

Online published: 2023-01-09

Fold

摘要

为深入探究低渗透油藏空气驱开发过程中原油的氧化特征及其影响因素,评价其驱油效果,以新疆油田低渗透油藏为研究对象,开展原油组分分析、原油氧化特征、空气驱及空气泡沫驱等实验,系统研究了不同条件下原油氧化特征及规律。实验结果表明:相同条件下,油砂比纯油样静态氧化反应速率大,反应充分,且反应速率与反应压力、温度、作用时间呈正相关;油藏温度下,原油经历氧化反应后轻重比减小,主峰碳增加;反应温度对空气驱原油动态氧化特征有较大影响,温度越高耗氧量越大,反应越充分;空气驱具有较好驱油效果,但易发生气窜;泡沫驱可有效封堵气窜通道,扩大空气波及体积,改善空气驱效果。研究成果对空气驱理论研究及应用具有借鉴意义。

关键词： 低渗透油藏; 空气驱; 氧化机理; 氧化特征; 驱油效果; 实验研究

本文引用格式

滕卫卫 , 吴庆祥 , 胡晓蝶 , 王晓光 , 程宏杰 , 朱桂芳 . 低渗透油藏空气驱原油氧化机理实验[J]. 特种油气藏, 2022 , 29(3) : 104 -111 . DOI: 10.3969/j.issn.1006-6535.2022.03.015

Abstract

In order to deeply investigate the oxidation characteristics of crude oil and its influencing factors during the development by air flooding of low permeability reservoirs and evaluate its oil displacement efficiency, experiments on crude oil component analysis, oxidation characteristics of crude oil, air flooding and air-foam flooding were conducted to systematically study the oxidation characteristics and laws of crude oil under different conditions, taking the representative reservoirs of low permeability in Xinjiang Oilfield as the study object. The experimental results showed that, under the same conditions, the static oxidation reaction rate of oil sand was higher than and the reaction was more sufficient than that of pure oil sample, and the reaction rate was positively correlated with the reaction pressure, temperature and action time; at the reservoir temperature, the weight ratio of crude oil after oxidation reaction decreased, and the main peak carbon increased; the reaction temperature had a great influence on the dynamic oxidation characteristics of crude oil in air flooding, the higher the temperature, the greater the oxygen consumption and the more sufficient the reaction; the air flooding was effective in oil displacement, with gas channeling easy to occur; the foam flooding could effectively block the gas channeling channel, expand the air swept volume, and improve the air flooding effect. The study results have an exemplary significance regarding the theoretical research and application of air flooding.

Key words： low permeability reservoir; air flooding; oxidation mechanism; oxidation characteristics; oil displacement effect; experimental study

参考文献

[1] 曹学良,郭平,杨学峰,等.低渗透油藏注气提高采收率前景分析[J].天然气工业,2006,26(3):100-102.
CAO Xueliang,GUO Ping,YANG Xuefeng,et al.An analysis of prospect of EOR by gas injection in low-permeability oil reservoir[J].Natural Gas Industry,2006,26(3):100-102.
[2] 祝云昭.浅析低渗透油藏开发方法[J].石化技术,2019,26(4):110-116.
ZHU Yunzhao.A brief analysis of low permeability reservoir development methods[J].Petrochemical Industry Technology,2019,26(4):110-116.
[3] 蒋有伟,张义堂,刘尚齐,等.低渗透油藏注空气开发驱油机理[J].2010,37(4):471-476.
JIANG Youwei,ZHANG Yitang,LIU Shangqi,et al.Displacement mechanisms of air injection in low permeability reservoirs[J].2010,37(4):471-476.
[4] 贾瑞轩,孙灵辉,苏致新,等.二氧化碳吞吐致密油藏的可动用性[J].断块油气田,2020,27(4):504-508.
JIA Ruixuan,SUN Linghui,SU Zhixin,et al.Availability of CO₂ huff and puff in tight reservoir[J].Fault-Block Oil & Gas Field,2020,27(4):504-508.
[5] 田巍.CO₂驱提高采收率方法在深层低渗透油藏的应用[J].石油地质与工程,2020,34(4):50-54.
TIAN Wei.Application of CO₂-EOR in the deep low permeability reservoir[J].Petroleum Geology & Engineering,2020,34(4):50-54.
[6] 雷欣慧,郑自刚,余光明,等.特低渗油藏水驱后二氧化碳气水交替驱见效特征[J].特种油气藏,2020,27(5):113-117.
LEI Xinhui,ZHENG Zigang,YU Guangming,et al.Response characteristics of gas-water alternate flooding with CO₂ after water flooding in ultra-low permeability reservoirs[J].Special oil & Gas Reservoirs,2020,27(5):113-117.
[7] 曹维政,罗琳,张丽平,等.特低渗透油藏注空气/氮气室内实验研究[J].大庆石油地质与开发,2008,27(2):113-117.
CAO Weizheng,LUO Lin,ZHANG Liping,et al.Laboratory experiment on air injection and nitrogen injection in extra-low permeability reservoir[J].Petroleum Geology & Oilfield Development in Daqing,2008,27(2):113-117.
[8] 张旭,刘建仪,易洋,等.注气提高采收率技术的挑战与发展[J].特种油气藏,2006,13(1):6-9.
ZHANG Xu,LIU Jianyi,YI Yang,et al.The challenge and progress of gas injection EOR-air injection LTO technology[J].Special Oil & Gas Reservoirs,2006,13(1):6-9.
[9] 赵斌,高海涛,杨卫东.中原油田注空气提高采收率潜力分析[J].油气田地面工程,2005,24(5):22-23.
ZHAO Bin,GAO Haitao,YANG Weidong.Potential analysis of air injection for enhanced oil recovery in Zhongyuan Oilfield[J].Oil-Gas Field Surface Engineering,2005,24(5):22-23.
[10] 李凯凯,杨其彬.空气驱油安全控制研究[J].断块油气田,2008,15(5):93-95.
LI Kaikai,YANG Qibin.Safety control of air injection displacement[J].Fault-Block Oil & Gas Field,2008,15(5):93-95.
[11] 梁承春,聂法健,张戈.红河油田长₈油藏减氧空气驱注气参数综合优化[J].石油地质与工程,2020,34(4):55-59.
LIANG Chengchun,NIE Fajian,ZHANG Ge,et al.Comprehensive optimization of gas injection parameters for oxygen-reduced air flooding in Chang₈ reservoir of Honghe Oilfield[J].Petroleum Geology & Engineering,2020,34(4):55-59.
[12] 张鸿,王岐,马宝全.潜山油藏减氧空气驱室内实验研究[J].石油地质与工程,2021,35(6):68-72.
ZHANG Hong,WANG Qi,MA Baoquan.Laboratory experimental study on oxygen reducing air flooding in buried hill reservoir[J].Petroleum Geology & Engineering,2021,35(6):68-72.
[13] 何应付,赵淑霞,计秉玉,等.砂岩油藏CO₂驱提高采收率油藏筛选与潜力评价[J].油气地质与采收率,2020,27(1):140-145.
HE Yingfu,ZHAO Shuxia,JI Bingyu,et al.Screening method and potential evaluation for EOR by CO₂ flooding in sandstone reservoirs[J].Petroleum Geology and Recovery Efficiency,2020,27(1):140-145.
[14] 郭小哲,曹玉峰,田凯.深层稠油减氧空气吞吐注气量确定方法研究[J].西南石油大学学报(自然科学版),2021,43(2):110-116.
GUO Xiaozhe,CAO Yufeng,TIAN Kai.A study on optimized method of gas injection volume of the oxygen-reduced air flooding in deep heavy oil reservior[J].Journal of Southwest Petroleum University (Science & Technology Edition),2021,43(2):110-116.
[15] 张越琪,苟利鹏,乔文波,等.致密油藏超临界二氧化碳吞吐开发特征实验研究[J].特种油气藏,2021,28(1):130-135.
ZHANG Yueqi,GOU Lipeng,QIAO Wenbo,et al.Experimental study on development characteristics of supercritical CO₂ huff and puff in tight oil reservoirs[J].Special Oil & Gas Reservoirs,2021,28(1):130-135.
[16] 白凤瀚,申友清,孟庆春,等.雁翎油田注氮气提高釆收率现场试验[J].石油学报,1998,19(4):61-68.
BAI Fenghan,SHEN Youqing,MENG Qingchun,et al.Reservoir engineering research of the nitrogen injection pilot in Yanling Oil Field[J].Acta Petrolei Sinica,1998,19(4):61-68.
[17] 吕鑫,岳湘安,吴永超,等.空气泡沫驱提高采收率技术的安全性分析[J].油气地质与采收率,2005,12(5):44-46.
LYU Xin,YUE Xiang'an,WU Yongchao,et al.Safety analysis of enhancing oil recovery by air-foam flooding[J].Petroleum Geology and Recovery Efficiency,2005,12(5):44-46.
[18] 张积耀,高瑞民,余华贵,等.低温低压油藏注空气提高采收率耗氧初探[J].油气地质与采收率,2012,19(5):81-83.
ZHANG Jiyao,GAO Ruimin,YU Huagui,et al.Preliminary study about oxygen consumption of injecting air into low-temperature and low-pressure reservoir[J].Petroleum Geology and Recovery Efficiency,2012,19(5):81-83.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献