砂砾岩油藏原位乳化提高采收率实验研究

罗强; 李明; 李凯; 宁朦; 贺伟; 杜代军

doi:10.3969/j.issn.1006-6535.2023.01.014

特种油气藏 >

2023 , Vol. 30 >Issue 1: 100 - 106

DOI: https://doi.org/10.3969/j.issn.1006-6535.2023.01.014

油藏工程

砂砾岩油藏原位乳化提高采收率实验研究

罗强 ,
李明 ,
李凯 ,
宁朦 ,
贺伟 ,
杜代军

展开

1.中国石油新疆油田分公司,新疆克拉玛依 834000;
2.西南石油大学提高采收率工程联合实验室,新疆,克拉玛依 834000;
3.西南石油大学油气藏地质及开发工程国家重点实验室,四川成都 610500

罗强(1972—),男,高级工程师,1995年毕业于乐山师范学院生物专业,2008年毕业于西南石油大学油气田开发工程专业,获博士学位,现从事提高采收率工作。

收稿日期: 2022-03-25

修回日期: 2022-11-04

网络出版日期: 2023-03-24

基金资助

国家自然科学基金“黏度可控的原位增黏体系构建及高效驱油机理研究”(U19B2010)

收起

Experimental Study on In-situ Emulsification Enhanced Oil Recovery of Glutenite Oil Reservoir

Luo Qiang ,
Li Ming ,
Li Kai ,
Ning Meng ,
He Wei ,
Du Daijun

Expand

1. PetroChina Xinjiang Oilfield Company, Karamay, Xinjiang 834000, China;
2. Joint Laboratory of Recovery Enhancement Engineering of Southwest Petroleum University, Karamay, Xinjiang 834000, China;
3. State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Chengdu, Sichuan 610500, China

Received date: 2022-03-25

Revised date: 2022-11-04

Online published: 2023-03-24

Fold

摘要

针对砂砾岩油藏非均质性强的特点,提出了一种原位乳化提高采收率技术,对新型W/O型乳化体系(DMS)开展了乳化性能、降低界面张力性能以及驱油性能研究,同时与油田现场用聚合物-表面活性剂二元体系进行了对比。实验结果表明:不同含水率下DMS能够与原油发生乳化形成W/O型乳液,随着含水率的增大,乳液黏度增高,在含水率为70%时黏度达到最大值,为原油黏度的9倍,远高于二元体系的黏度,流度控制能力更强;DMS能够定向吸附于油水界面,将油水界面张力降低至0.12 mN/m;受拉伸卡断作用,在DMS的作用下油水发生原位乳化形成W/O型乳液,乳液粒径为0.5～6.0 μm;砂砾岩岩心进行DMS驱以及后续水驱能够提高采收率18.6%,当渗透率级差为10时,二元驱及后续水驱能提高采收率24.0%,而DMS驱以及后续水驱能够提高采收率35.3%,表现出更好的流度控制以及吸水剖面改善能力。研究结果为砂砾岩油藏提高采收率提供理论支撑。

关键词： 砂砾岩; 原位乳化; W/O型乳液; 非均质性调控; 提高采收率

本文引用格式

罗强 , 李明 , 李凯 , 宁朦 , 贺伟 , 杜代军 . 砂砾岩油藏原位乳化提高采收率实验研究[J]. 特种油气藏, 2023 , 30(1) : 100 -106 . DOI: 10.3969/j.issn.1006-6535.2023.01.014

Abstract

In view of the strong heterogeneity of the glutenite oil reservoir, an in situ emulsification enhanced oil recovery technology was proposed. The emulsification performance, interfacial tension reduction performance and oil displacement performance of the new W/O emulsification system (DMS) were studied, and at the same time the results were compared with the polymer/surfactant binary system used in the oil field. The experimental result shows that under different water contents, DMS can emulsify with crude oil to form W/O emulsion. With the increase of water content, the viscosity of emulsion increases. When the water content is 70%, the viscosity reaches the maximum value, which is 9 times of the viscosity of crude oil, much higher than the viscosity of binary system, and the fluidity control ability is stronger. DMS can be directionally adsorbed on the oil-water interface and reduce the oil-water interfacial tension to 0.12mN/m. Under the influence of DMS, oil and water are emulsified in situ to form W/O emulsion with a particle size of 0.5-6.0μm. In the glutenite core, DMS flooding and subsequent water flooding can improve the recovery by 18.6%. Under the permeability max-min ratio of 10, dual flooding and subsequent water flooding can improve the recovery by 24.0%, while DMS flooding and subsequent water flooding can improve the recovery by 35.3%, showing better fluidity control and the ability to improve the water absorption profile. The research result will provide theoretical support for enhanced oil recovery of glutenite oil reservoir

Key words： glutenite; in situ emulsification; W/O emulsion; heterogeneous regulation; enhanced oil recovery

参考文献

[1] XU C F,LIU H X,QIAN G B.Microcosmic mechanisms of water-oil displacement in conglomerate reservoirs in Karamay Oilfield[J].Petroleum Exploration and Development,2011,38:725-732.
[2] 陈勇,翟明洋.基于岩心脆性特征的致密砂砾岩储层水力裂缝复杂性分析[J].油气地质与采收率,2020,27(5):33-43.
CHEN Yong,ZHAI Mingyang.Complexity analysis of hydraulic fracture in tight glutenite reservoir based on core brittleness[J].Petroleum Geology and Recovery Efficiency,2020,27(5):33-43.
[3] ZHAO J Z,JIA H.PU W F.Influences of fracture aperture on the water shut-off performance of polyethyleneimine cross-linking partially hydrolyzed polyacrylamide gels in hydraulic fractured reservoirs[J].Energy Fuels,2011,25:2616-2624.
[4] BAI B J,WEI M Z,LIU Y Z.Injecting large volumes of preformed particle gel for water conformance control[J].Oil & Gas Science and Technology,2012,67:941-952.
[5] LIU R,PU W F,DU D J.Synthesis and characterization of core-shell associative polymer that prepared by oilfield formation water for chemical flooding[J].Journal of Industrial and Engineering Chemistry,2017,46:80-90.
[6] LIU Z,LI Y,LYU J.Optimization of polymer flooding design in conglomerate reservoirs[J].Journal of Petroleum Science and Engineering,2017,152:267-274.
[7] 徐辉,宋敏,孙秀芝,等.新型耐特高温抗水解型聚合物驱油性能[J].油气地质与采收率,2021,28(4):101-106.
XU Hui,SONG Min,SUN Xiuzhi,et al.Study on oil displacement performance of a new type of polymer with ultra-high temperature and hydrolysis resistance[J].Petroleum Geology and Recovery Efficiency,2021,28(4):101-106.
[8] 陈斌,曹小华,周亮,等.适用于高温高盐低渗砂岩油藏的表面活性剂驱油体系[J].钻采工艺,2021,44(3):87-91.
CHEN Bin,CAO Xiaohua,ZHOU Liang,et al.Surfactant flooding system for high temperature and high salinity of low permeability sandstone reservoirs[J].Drilling & Production Technology,2021,44(3):87-91.
[9] 任璐,刘爱玲,张天琪,等.基于临界胶束浓度的三元复合驱采出水稳定性研究[J].吉林化工学院学报,2021,38(11):19-23.
REN Lu,LIU Ailing,ZHANG Tianqi,et al.Study on the stability of asp flooding produced water based on critical micelle concentration[J].Journal of Jilin Institute of Chemical Technology,2021,38(11):19-23.
[10] 吕其超,张洪生,左博文,等.特高含水期微乳液驱油规律微观可视化实验研究[J].西安石油大学学报(自然科学版),2020,35(2):71-77.
LYU Qichao,ZHANG Hongsheng,ZUO Bowen,et al.Microscopic visualization study of microemulsion flooding law in ultra-high water cut stage[J].Journal of Xi′an Shiyou University(Natural Science Edition),2020,35(2):71-77.
[11] 宁健,魏兵,高炎,等.低成本O/W型乳液与岩心孔喉配伍性及其驱油效率[J].油田化学,2018,35(2):328-332.
NING Jian,WEI Bing,GAO Yan,et al.Oil displacement efficiency and pore size matching of an economic O/W emulsion flooding[J].Oilfield Chemistry,2018,35(2):328-332.
[12] 任朝华,张先超,尤万里,等.乳化剂HC-5的性能及驱油效果[J].油田化学,2015,32(4):554-558.
REN Chaohua,ZHANG Xianchao,YOU Wanli,et al.Performance and oil displacement effect of emulsifier HC-5[J].Oilfield Chemistry,2015,32(4):554-558.
[13] 宣英龙,杨雪白,秦笃国,等.扶余原油乳化生成条件与驱油机理[J].油田化学,2016,33(2):300-304.
XUAN Yinglong,YANG Xuebai,QIN Duguo,et al.Formation condition of emulsion and oil-displacement mechanism in Fuyu Oilfield[J].Oilfield Chemistry,2016,33(2):300-304.
[14] 周亚洲,殷代印,曹睿.高含水后期乳状液的驱油效果与作用机理分析[J].油田化学,2016,33(2):285-290.
ZHOU Yazhou,YIN Daiyin,CAO Rui.Research on profile control and displacement mechanism of discontinuous emulsion in late high water-cut stage[J].Oilfield Chemistry,2016,33(2):285-290.
[15] 田茂章,赵新,宋新民,等.低渗透油藏中油包水乳液的生成及其扩大波及体积的作用[J].应用化工,2015,44(8):1421-1426.
TIAN Maozhang,ZHAO Xin,SONG Xinmin,et al.Transition from O/W to W/O and its action on improving sweep efficiency in low permeability reservoirs[J].Applied Chemical Industry,2015,44(8):1421-1426.
[16] 蒲万芬,梅子来,杨洋,等.高含水高温油藏W/O型乳化剂OB-2性能评价及驱油研究[J].油气藏评价与开发,2019,9(1):38-43.
PU Wanfen,MEI Zilai,YANG Yang,et al.Evaluation of OB-2 system for W/O emulsifier and displacement experiments research at high temperature reservoir in high water cut period[J].Reservoir Evaluation and Development,2019,9(1):38-43.
[17] DU D,PU W,CHEN B,et al.Experimental study on EOR potential of water-in-oil emulsion via CO₂/N₂ triggered wormlike micelle solution[J].Fuel,2021,288:119639.
[18] 尹红佳,马强,胡晓雪,等.低渗透油藏提高水驱效率技术对策[J].石油地质与工程,2021,35(1):77-81.
YIN Hongjia,MA Qiang,HU Xiaoxue,et al. Technical countermeasures for improving water drive efficiency in low permeability reservoirs[J]. Petroleum Geology & Engineering, 2021, 35(1): 77-81.
[19] 钱川川,骆飞飞,蒋志斌,等.注空气提高低渗透油藏采收率实验及低温氧化反应特征[J].大庆石油地质与开发,2022,41(1):97-103.
QIAN Chuanchuan,LUO Feifei,JIANG Zhibin,et al. EOR experiment of air injection and low-temperature oxidation reaction characteristics in low-permeability reservoirs[J]. Petroleum Geology & Oilfield Development in Daqing,2022,41(1):97-103.
[20] 陈民锋,杨子由,秦立峰,等.低渗透各向异性油藏菱形井网储量动用评价及设计优化[J].石油与天然气地质,2021,42(5):1223-1233.
Chen Minfeng,Yang Ziyou,Qin Lifeng,et al.Producing reserve estimation and design optimization of rhomboid well pattern in anisotropic reservoirs of low permeability[J].Oil & Gas Geology,2021,42(5):1223-1233.
[21] 李艳.鄂尔多斯盆地特低渗透油藏降压增注复合表面活性剂体系研制及性能评价[J].大庆石油地质与开发,2022,41(1):104-110.
LI Yan.System development and performance evaluation of depressurizing and injection enhancing complex surfactant in the ultra-low permeability oil reservoirs of Ordos Basin[J]. Petroleum Geology & Oilfield Development in Daqing,2022,41(1):104-110.
[22] 王建忠,宋宪坤,付颖超,等.水驱砂岩油藏在不同水质下的渗透率时变特征[J].石油与天然气地质,2021,42(5):1234-1242.
Wang Jianzhong,Song Xiankun,Fu Yingchao,et al.Time-varying permeability of sandstone reservoirs under waterflooding of different water quality[J].Oil & Gas Geology,2021,42(5):1234-1242.
[23] 王文明,衣晓东,殷代印.应用激光共聚焦研究特低渗透储层微观剩余油分布[J].石油地质与工程,2021,35(2):50-55.
WANG Wenming,YI Xiaodong,YIN daiyin,et al. Microscopic remaining oil distribution in ultra-low permeability reservoir by laser confocal method[J].Petroleum Geology & Engineering, 2021, 35(2):50-55.
[24] 瞿朝朝,刘斌,宋洪亮,等.基于动静态资料综合判断聚驱后的油藏井间连通性[J].石油地质与工程,2021,35(2):76-79.
QU Zhaozhao,LIU Bin,SONG Hongliang,et al. Inter well connectivity of reservoir after polymer flooding based on dynamic and static data coupling judgment method[J].Petroleum Geology & Engineering, 2021, 35(2):76-79.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献