济阳坳陷油页岩力学性能特征实验

王爱民; 王发明; 贺文卿; 王帅; 刘厚彬

doi:10.3969/j.issn.1006-6535.2023.05.019

特种油气藏 >

2023 , Vol. 30 >Issue 5: 144 - 150

DOI: https://doi.org/10.3969/j.issn.1006-6535.2023.05.019

钻采工程

济阳坳陷油页岩力学性能特征实验

王爱民 ,
王发明 ,
贺文卿 ,
王帅 ,
刘厚彬

展开

1.中国石化胜利油田分公司,山东东营 257000;
2.西南石油大学油气藏地质及开发工程国家重点实验室,四川成都 610500

王爱民(1966—),男,高级工程师,1987年毕业于胜利石油学校钻井工程专业,2006年毕业于中国石油大学(华东)石油工程专业,获学士学位,现主要从事现场钻井技术及监督管理工作。

收稿日期: 2023-01-03

修回日期: 2023-06-10

网络出版日期: 2023-12-25

基金资助

国家自然科学基金“干热岩型地热泡沫钻井流体相变行为下井筒温度压力响应特性研究”(52174008)

收起

Experimental on Mechanical Properties Characteristics of Oil Shale in Jiyang Depression

Wang Aimin ,
Wang Faming ,
He Wenqing ,
Wang Shuai ,
Liu Houbin

Expand

1. Sinopec Shengli Oilfield Company, Dongying, Shandong 257000, China;
2. State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Chengdu, Sichuan 610500, China

Received date: 2023-01-03

Revised date: 2023-06-10

Online published: 2023-12-25

Fold

摘要

济阳坳陷页岩油勘探开发成效显著,但大斜度水平井井壁垮塌异常突出,多次引发井下阻卡,甚至埋钻事故。针对上述问题,通过岩石力学室内系列实验研究油页岩力学性能与崩塌破坏规律,剖析油页岩水平井井壁失稳机理与主控因素。研究表明:油页岩岩体裂缝极为发育,主要为近平行低角度层理缝,伴有高角度交叉缝,岩体破碎程度高;油页岩力学参数各向异性特征明显,当井壁最大主应力与层理缝垂直时,井壁整体力学强度最大,随着井壁最大主应力与层理缝面夹角减小,井壁力学强度呈减小趋势,当夹角为60 °左右时力学强度最低,井壁稳定性最差;济阳坳陷油页岩整体力学强度低,井下应力环境下抗压强度最大值为165 MPa,最低仅为52 MPa;油页岩岩体破坏方式存在差异,当井壁最大主应力与层理缝面夹角较小时,以沿层理缝间剪切滑移破坏为主,反之为油页岩基岩剪切破坏。济阳坳陷油页岩井壁失稳作用机理研究成果可为油页岩大斜度水平井井壁稳定性预测及工程参数优化设计提供支撑。

关键词： 济阳坳陷; 油页岩; 力学强度各向异性; 钻井液浸泡作用

本文引用格式

王爱民 , 王发明 , 贺文卿 , 王帅 , 刘厚彬 . 济阳坳陷油页岩力学性能特征实验[J]. 特种油气藏, 2023 , 30(5) : 144 -150 . DOI: 10.3969/j.issn.1006-6535.2023.05.019

Abstract

The exploration and development of shale oil in Jiyang Depression had achieved remarkable results, but the wall collapse of highly deviated horizontal wells was extremely prominent, which has repeatedly caused downhole jamming and even drilling accidents. In response to the problems above, the mechanical properties of oil shale and collapse damage law were studied through a series of indoor experiments on rock mechanics, and the mechanism and main control factors of oil shale horizontal wellbore destabilization were analyzed. The study shows that the oil shale rock fractures are extremely developed, mainly of the subparallel low-angle bedding fractures, accompanied by high-angle cross fractures, and the rock fragmentation is high; the mechanical parameters of oil shale have obvious anisotropy characteristics.When the maximum principal stress of the wellbore is perpendicular to the bedding fractures, the overall mechanical strength of the wellbore is the highest, and as the angle between the maximum principal stress and the bedding fractures decreases, the mechanical strength of the wellbore tends to decrease, and when the angle is about 60 °, the mechanical strength is the lowest, and the wellbore stability is the worst.The overall mechanical strength of the oil shale in Jiyang Depression is low, and the maximum compressive strength under downhole stress is 165 MPa, and the lowest is only 52 MPa; there is a difference in the damage mode of the oil shale rock, when the angle between the maximum principal stress and the bedding fracture surface in the wellbore is small, the main damage is the shear slip damage along the bedding fracture, otherwise, the main damage is the oil shale bedrock shear damage. The study results of the destabilization mechanism of oil shale wellbore in Jiyang Depression can provide support for the prediction of wellbore stability and the optimal design of engineering parameters for the highly deviated horizontal wells in oil shale.

Key words： Jiyang Depression; oil shale; mechanical strength anisotropy; drilling fluid immersion

参考文献

[1] 李术元,何继来,侯吉礼,等.世界油页岩勘探开发加工利用近况 [J].中外能源,2015,20(1):25-32.
LI Shuyuan,HE Jilai,HOU Jili,et al.Current status of the world's exploration and utilization of oil shale[J].Sino-Global Energy,2015,20(1):25-32.
[2] 王清强,马跃,李术元,等.世界油页岩资源研究开发利用近况 [J].中外能源,2017,22(1):23-29.
WANG Qingqiang,MA Yue,LI Shuyuan,et al.Global oil shale research,development and utilization today[J].Sino-Global Energy,2017,22(1):23-29.
[3] 刘招君,柳蓉,孙平昌,等.中国典型盆地油页岩特征及赋存规律[J].吉林大学学报(地球科学版),2020,50(2):313-325.
LIU Zhaojun,LIU Rong,SUN Pingchang,et al.Oil shale characteristics and distribution in typical basins of China[J].Journal of Jilin University(Earth Science Edition),2020,50(2):313-325.
[4] 侯吉礼,马跃,李术元,等.世界油页岩资源的开发利用现状[J].化工进展,2015,34(5):1183-1190.
HOU Jili,MA Yue,LI Shuyuan,et al.Development and utilization of oil shale worldwide[J].Chemical Industry and Engineering Progress,2015,34(5):1183-1190.
[5] ESEMEE,KROOSSBM,LITTKER.Evolution of petrophysical properties of oil shales during high-temperature compaction tests:implications for petroleum expulsion[J].Marine & Petroleum Geology, 2012, 31(1):110-124.
[6] ENNO reinsalu.Investigation of the physical properties of oil shale of the Estonian deposit[J].Oil Shale,2014,31(3):304-311.
[7] VIVIKA Vãizene,INGO Valgma,ENNO Reinsalu,et al.Interdependence between point load index,compressive strength and crushing resistance of Jordan oil shale and relation to calorific value[J].Oil Shale,2015,32(3):252-268.
[8] 梁冰,兰波,王俊光.水影响下油页岩三轴压缩力学特性实验研究[J].山东大学学报(工学版),2011,41(5):82-85,102.
LIANG Bing,LAN Bo,WANG Junguang.Tri-axial compression test study on mechanical characteristics of oil shale under the water[J].Journal of Shandong University(Engineering Science),2011,41(5):82-85,102.
[9] 严轩辰.农安和桦甸油页岩力学性能及其水力压裂与破碎关键参数研究[D].长春:吉林大学,2012.
YAN Xuanchen.Research on the mechanical properties of Nong'an and Huadian oil shale and its key parameters of hydraulic fracturing and fracture[D].Changchun:Jilin University,2012.
[10] 刘志军,杨栋,邵继喜.温度影响下油页岩动力学参数的实验研究[J].黑龙江科技大学学报,2017,27(4):396-399.
LIU Zhijun,YANG Dong,SHAO Jixi.Experimental research on dynamic parameter of oil shale under temperature effect[J].Journal of Heilongjiang University of Science and Technology,2017,27(4):396-399.
[11] 耿毅德,梁卫国,刘剑,等.高温及三轴应力条件下抚顺油页岩渗透规律试验研究[J].太原理工大学学报,2019,50(3):272-278.
GENG Yide,LIANG Weiguo,LIU Jian,et al.Experimental study on the law with permeability of Fushun oil shale under high temperature and triaxial stresses[J].Journal of Taiyuan University of Technology(Social Science Edition),2019,50(3):272-278.
[12] 徐兴倩,刘剑,屈新,等.热解过程中油页岩弹性模量变化规律[J].长江科学院院报,2021,38(3):110-114.
XU Xingqian,LIU Jian,QU Xin,et al.Variation rules of elastic modulus of oil shale during pyrolysis[J].Journal of Yangtze River Scientific Research Institute,2021,38(3):110-114.
[13] 李新.页岩气储层岩石物理实验及可压裂性表征研究[D].西安:西北大学,2016.
LI Xin.Research on petrophysical experiment and fracturing characterization of shale gas reservoir[D].Xi'an:Northwest University,2016.
[14] 刘厚彬,崔帅,孟英峰,等.裂缝性碳酸盐岩微细观组构及力学性能研究[J].特种油气藏,2020,27(1):155-161.
LIU Houbin,CUI Shuai,MENG Yingfeng,et al.Micro-mechanical structure and mechanical properties of fractured carbonate rock[J].Special Oil & Gas Reservoirs,2020,27(1):155-161.
[15] 衡帅,杨春和,张保平,等.页岩各向异性特征的试验研究[J].岩土力学,2015,36(3):609-616.
HENG Shuai,YANG Chunhe,ZHANG Baoping,et al.Experimental research on anisotropic properties of shale[J].Rock and Soil Mechanics,2015,36(3):609-616.
[16] 王香增,张建锋,郝世彦.延安地区陆相页岩气勘探开发关键技术[J].非常规油气,2023,10(1):1-10.
WANG Xiangzeng,ZHANG Jianfeng,HAO Shiyan.Key technologies of continental shale gas exploration and development in Yan'an Area[J].Unconventional Oil & Gas,2023,10(1):1-10.
[17] 李进, 王学军, 周凯,等.海陆过渡相超深层页岩储层特征——以川东北普光气田Y4井上二叠统龙潭组下段为例[J]. 石油实验地质, 2022, 44(1): 71-84.
LI Jin, WANG Xuejun, ZHOU Kai, et al. Characteristics of ultra-deep shale reservoir of marine-continental transitional facies: a case study of lower member of Upper Permian Longtan Formation in Well Y4, Puguang Gas Field, northeastern Sichuan Basin[J]. Petroleum Geology & Experiment, 2022, 44(1): 71-84.
[18] 赵迪斐,张家明,郭英海,等.储层精细评价潜在关键关联指标:页岩沉积构造及其量化问题研究评述[J].非常规油气,2023,10(1):11-20.
ZHAO Difei,ZHANG Jiaming,GUO Yinghai,et al.Potential key correlation index for fine reservoir evaluation:review on shale sedimentary structure and its quantification[J].Unconventional Oil & Gas,2023,10(1):11-20.
[19] 高波, 武晓玲, 张英,等.鄂尔多斯盆地南部张家滩油页岩生烃演化特征[J]. 石油实验地质, 2022, 44(1): 24-32.
GAO Bo, WU Xiaoling, ZHANG Ying, et al. Hydrocarbon generation and evolution characteristics of Triassic Zhangjiatan oil shale in southern Ordos Basin[J]. Petroleum Geology & Experiment, 2022, 44(1): 24-32.
[20] 张晴,任重阳,张然舜,等.基于文献计量特征的我国深层页岩研究进展及趋势(2012—2022)[J].非常规油气,2023,10(1):21-26.
ZHANG Qing,REN Chongyang,ZHANG Ranshun,et al.Progress and trends of China's deep shale gas research based on bibliometric analysis(2012—2022)[J].Unconventional Oil & Gas,2023,10(1):21-26.
[21] 冯东,唐永槐,李阳,等.延安地区陆相页岩气动态储量计算方法研究[J].非常规油气,2023,10(1):27-31,43.
FENG Dong,TANG Yonghuai,LI Yang,et al.Dynamic reserves calculation method of continental shale gas in Yan'an Area[J].Unconventional Oil & Gas,2023,10(1):27-31,43.
[22] 温宏雷, 杨海风, 杨波,等.渤海海域莱北低凸起新近系岩性油藏成藏模式及勘探实践[J]. 石油实验地质, 2022, 44(1): 102-111.
WEN Honglei,YANG Haifeng,YANG Bo, et al. Exploration advances and accumulation model for Neocene lithological reservoirs in Laibei Low Uplift, Bohai Sea Area[J]. Petroleum Geology & Experiment, 2022, 44(1): 102-111.
[23] 程奇,刘宗宾,王建立,等. 变质岩潜山储层结构及其生产动态响应:以渤海锦州25-1南油田为例[J]. 东北石油大学学报,2022,46(1):26-35.
CHENG Qi,LIU Zongbin,WANG Jianli,et al. Reservoir structure and production dynamic response of metamorphic buried hill:taking JZ25-1S Oilfield in Bohai Sea as an example[J]. Journal of Northeast Petroleum University,2022,46(1):26-35.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献