低黏原油辅助气体吞吐稠油开采技术室内实验和技术界限

户昶昊

doi:10.3969/j.issn.1006-6535.2024.01.006

特种油气藏 >

2024 , Vol. 31 >Issue 1: 48 - 56

DOI: https://doi.org/10.3969/j.issn.1006-6535.2024.01.006

油藏工程

低黏原油辅助气体吞吐稠油开采技术室内实验和技术界限

户昶昊

展开

1.中国石油辽河油田分公司,辽宁盘锦 124010;
2.国家能源稠(重)油开采研发中心,辽宁盘锦 124010

户昶昊(1979—),男,教授级高级工程师,《特种油气藏》主编,2002年毕业于中国地质大学(武汉)石油工程专业,2010年毕业于中国石油大学(华东)石油与天然气工程专业,获硕士学位,现主要从事油气田开发研究和管理工作。

收稿日期: 2023-12-06

修回日期: 2024-01-16

网络出版日期: 2024-04-18

基金资助

中国石油科技专项“稠油大幅度提高采收率关键技术研究”(2023ZZ23)

收起

Indoor Experiment and Technical Boundary of Heavy Reservoir with Gas Huff and Puff Assisted by Low-Viscosity Oil Injection

HU Changhao

Expand

1. PetroChina Liaohe Oilfield Company, Panjin, Liaoning, 124010;
2. Viscous (Heavy) Oil Recovery Research Center of National Energy Bureau, Panjin, Liaoning, 124010

Received date: 2023-12-06

Revised date: 2024-01-16

Online published: 2024-04-18

Fold

摘要

稠油蒸汽吞吐后期及蒸汽驱的油汽比仅为0.1～0.2,能耗大、碳排量高等问题突出,针对该问题,可利用低黏原油辅助气体吞吐的开采方法来改善开发效果。通过室内模拟实验和油藏数值模拟,开展低黏原油辅助气体吞吐开采稠油的机理及油藏适应性研究,制订低黏原油辅助气体吞吐的技术界限。研究表明:低黏原油辅助气体吞吐开采机理主要为稀释降黏、溶解增压、扩大波及范围和乳化相变等作用,带油率(采出稠油与注入低黏原油的体积比)可达到1.00～3.00以上,且能耗低、产水少;低黏原油辅助气体吞吐适合开采普通稠油油藏和特稠油油藏,尤其适合深层、薄互层和小断块稠油油藏。该研究对稠油转换低黏原油辅助气体吞吐开发油藏筛选和工程设计具有指导意义。

关键词： 低黏原油; 气体; 吞吐; 稠油; 低碳; 带油率

本文引用格式

户昶昊 . 低黏原油辅助气体吞吐稠油开采技术室内实验和技术界限[J]. 特种油气藏, 2024 , 31(1) : 48 -56 . DOI: 10.3969/j.issn.1006-6535.2024.01.006

Abstract

In the late stage of steam huff and puff or steam flooding for the heavy oil reservoir, the oil-steam ratio is only 0.1 to 0.2, which leads to high energy consumption and carbon emissions. To address the issue, a recovery method that utilizes low-viscosity oil injection assisted heavy reservoir with gas huff and puff has been proposed to improve the development effect. Through indoor test and reservoir numerical simulation, the mechanism and applicability are studied, and the technical boundary are delimited. The study shows that the mechanism of heavy reservoir with gas huff and puff assisted by low-viscosity oil injection is mainly viscosity reduction by dilution, solution gas drive, swept volume expansion and facies change by emulsification. The oil-carrying rate (volume ratio of produced heavy oil to injected low-viscosity oil) can reach 1.00-3.00, and the energy consumption and the water production is low. The new method is suitable for conventional heavy oil reservoirs and extra-heavy oil reservoirs, especially for deep zones, thin interbedded and small fault blocks. This study has guiding significance for reservoir screening and engineering design of heavy reservoir with gas huff and puff assisted by low-viscosity oil injection.

Key words： low viscosity oil; gas; huff and puff; heavy oil; low carbon; oil-carrying rate

参考文献

[1]辛福义.井筒稠油降黏技术应用现状[J].内蒙古石油化工,2010,20(18):100-104,150.
XIN Fuyi,Application status of wellbore viscosity reduction for heavy oil[J].Inner Mongolia Petrochemical Industry, 2010,20(18):100-104,150.
[2]梁金国,王弥康,任英.注蒸气采油掺稀油生产工艺的进一步研究[J].石油大学学报(自然科学版),1991,15(6):46-51.
LIANG Jinguo, WANG Mikang, REN Ying.Further study on the production process of mixed light oil by steam injection[J].Journal of China University of Petroleum (Edition of Natural Sciences),1991,15(6):46-51.
[3]林日亿,李兆敏,王景瑞,等.塔河油田超深井井筒掺稀降黏技术研究[J].石油学报,2006,27(3):115-119.
LIN Riyi, LI Zhaomin, WANG Jingrui, et al.Study on viscosity reduction by light oil admixed of ultra-deep wellbore in Tahe Oilfield[J]. Acta Petrolei Sinica,2006,27(3):115-119.
[4]曹畅,罗君兰,刘磊,等.超深稠油注天然气气举降掺稀先导试验[J].大庆石油地质与开发,2019,38(1):116-120.
CAO Chang, LUO Junlan, LIU lei, et al. Pilot test of the viscosity reduction by the natural gas injection and lift for the extra-deep heavy oil[J]. Petroleum Geology & Oilfield Development in Daqing, 2019,38(1):116-120.
[5]杨祖国,赵海洋,王雷,等.一种超稠油注天然气与稀油复合降黏方法:ZL201810268713.4[P].2018-08-10.
YANG Zuguo, ZHAO Haiyang, WANG Lei, et al.A composite viscosity reduction method for ultra-heavy oil by injection of natural gas and light oil: ZL201810268713.4[P]. 2018-08-10.
[6]李宗阳,杨勇,王业飞,等.不同水油黏度比下乳化对稠油复合驱的影响[J].油气地质与采收率,2023,30(1):146-152.
LI Zongyang,YANG Yong,WANG Yefei,et al.Effects of emulsification on combination flooding in heavy oil reservoirs at different water-oil viscosity ratios[J].Petroleum Geology & Recovery Efficiency,2023,30(1):146-152.
[7]亓树成,彭小强,郝红永,等. 降黏剂及其施工工艺对火驱稠油油藏注采井间快速连通的影响[J].大庆石油地质与开发,2023,42(2):86-90.
QI Shucheng,PENG Xiaoqiang,HAO Hongyong,et al.Influence of viscosity reducer and its operation technique on rapid injector-producer connection in in-situ combustion heavy oil reservoirs[J].Petroleum Geology & Oilfield Development in Daqing,2023,42(2):86-90.
[8]赵健,张娜,蒋海岩,等.稠油高压火驱氧化特性实验研究[J].油气地质与采收率,2023,30(3):145-151.
ZHAO Jian,ZHANG Na,JIANG Haiyan,et al.Experimental study on oxidation characteristics of heavy oil reservoirs by high-pressure in-situ combustion[J].Petroleum Geology & Recovery Efficiency,2023,30(3):145-151.
[9]何永清,鲁霖懋,周其勇,等. 适合中深层稠油油藏的两亲性稠油乳化降黏剂的制备及性能评价[J].大庆石油地质与开发,2023,42(5):160-167.
HE Yongqing,LU Linmao,ZHOU Qiyong,et al.Preparation and performance evaluation of amphiphilic emulsified viscosity reducer for medium-deep heavy oil reservoirs[J]. Petroleum Geology & Oilfield Development in Daqing,2023,42(5):160-167.
[10] 束青林,胡婧,林军章,等.“益生菌”提高难采稠油采收率机理与技术实践[J].油气地质与采收率,2022,29(4):76-82.
SHU Qinglin,HU Jing,LIN Junzhang,et al.Mechanism and technical practice of enhancing oil recovery of hard-to-recover heavy oil reservoirs with probiotics[J].Petroleum Geology & Recovery Efficiency,2022,29(4):76-82.
[11] 姚秀田,徐宏光,张仲平,等. 稠油油藏多轮次吞吐阻流环的分布特征及突破开采技术[J].大庆石油地质与开发,2023,42(6):67-74.
YAO Xiutian,XU Hongguang,ZHANG Zhongping,et al.Distribution characteristics and breakthrough production technology of flow-restricted ring in multi-rounds huff-and-puff heavy oil reservoir[J].Petroleum Geology & Oilfield Development in Daqing,2023,42(6):67-74.
[12] 王鹏,徐海霞,陈兰,等.高温稠油掺稀降黏开采辅助降黏剂的研究与应用[J].钻采工艺,2018, 41(1): 95-98.
WANG Peng, XU Haixia, CHEN Lan, et al.Research and application of viscosity reducing by light oil admixed in high-temperature heavy oil[J].Drilling & Production Technology, 2018, 41(1): 95-98.
[13] 郭长会,何利民,辛迎春.稠油掺稀输送中掺稀比的优化[J].油气储运,2015,34(4):388-390.
GUO Changhui, HE Limin, XIN Yingchun.Optimization of light oil admix ratio in heavy oil thinning transportation[J].Oil & Gas Storage and Transportation,2015,34(4):388-390.
[14] 周克厚,缪云.热油吞吐室内实验研究与评价[J].油气地质与采收率,2011, 18(4):75-77,116.
ZHOU Kehou, MIAO Yun, Laboratory experimental research and evaluation of thermal oil huff and puff[J].Petroleum Geology and Recovery Efficiency,2011, 18(4):75-77, 116.
[15] 刘尧文.热油吞吐解堵机理研究与现场试验应用[J].内江科技,2008,15(7):98.
LIU Yaowen.Research on plugging removal mechanism of thermal oil huff and puff and field test application[J].Neijiang Technology,2008,15(7):98.
[16] 马新仿,张士诚,杨胜来,等.超稠油掺稀油开采实验及数值模拟研究[J].中国石油大学学报(自然科学版),2006,30(4):63-66.
MA Xinfang, ZHANG Shicheng, YANG Shenglai, et al.Experimental and numerical simulation on ultra-heavy oil mixed with light oil recovery[J].Journal of China University of Petroleum (Edition of Natural Sciences),2006,30(4):63-66.
[17] 唐晓东,陈亮,王豪,等.一种稠油催化改质降黏采输一体化方法及其装置:ZL200910167612.9[P].2013-05-29.
TANG Xiaodong, CHEN Liang, WANG Hao, et al. An integrated method and device for heavy oil upgrading and viscosity reduction production and transportation: ZL200910167612.9[P].2013-05-29.
[18] SHANE D Stark.Cold lake commercialization of the liquid addition to steam for enhancing recovery (laser) process[C]. IPTC16795,2013:5-10.
[19] COSKUNER Gokhan, HUANG Haibo.Enhanced oil recovery in post-chops cold heavy oil production with sand heavy oil reservoirs of Alberta and Saskatchewan part 2: field piloting of cycling solvent injection[C]. SPE199947-MS, 2020: 3-5.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献