基于离散元模拟的超声波振动作用下层理状页岩损伤分析

杨圳伟; 刘向君; 熊健

doi:10.3969/j.issn.1006-6535.2024.04.021

特种油气藏 >

2024 , Vol. 31 >Issue 4: 163 - 168

DOI: https://doi.org/10.3969/j.issn.1006-6535.2024.04.021

钻采工程

基于离散元模拟的超声波振动作用下层理状页岩损伤分析

杨圳伟 ,
刘向君 ,
熊健

展开

西南石油大学油气藏地质及开发工程全国重点实验室,四川成都 610500

杨圳伟(1995—),男,2021年毕业于西南石油大学城市地下空间工程专业,现为该校地质资源与地质工程专业在读硕士研究生,主要从事岩石力学与井壁稳定方面的研究。

收稿日期: 2023-08-26

修回日期: 2024-05-02

网络出版日期: 2024-09-20

基金资助

四川省自然科学基金“声波振动作用下页岩的结构演变特征和增渗机制”(2022NSFSC1065)

收起

Damage Analysis of Bedding Shale under Ultrasonic Vibration Based on Discrete Element Simulation

Yang Zhenwei ,
Liu Xiangjun ,
Xiong Jian

Expand

State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Chengdu, Sichuan 610500, China

Received date: 2023-08-26

Revised date: 2024-05-02

Online published: 2024-09-20

Fold

摘要

为探究超声波振动辅助页岩储层改造的可行性,通过数值模拟方法建立层理状页岩的离散元模型,模拟不同层理倾角的层理状页岩在超声波振动下的损伤情况。结果表明:振动方向与层理面的夹角对超声波振动的传播有显著影响,振动方向与层理面夹角越小,生成微裂纹越多;裂纹主要集中在靠近振动源的地方,离振动源较远处生成的微裂纹数量较少;超声波振动对层理状页岩的强度影响明显,可在页岩内部诱生大量微裂纹,页岩微观结构和物理性质发生变化,单轴抗压强度和弹性模量会显著降低。该研究为利用超声波振动对层理状页岩进行储层改造提供了理论基础。

关键词： 层理状页岩; 超声波振动; 单轴抗压强度; 数值模拟; 离散元模型

本文引用格式

杨圳伟 , 刘向君 , 熊健 . 基于离散元模拟的超声波振动作用下层理状页岩损伤分析[J]. 特种油气藏, 2024 , 31(4) : 163 -168 . DOI: 10.3969/j.issn.1006-6535.2024.04.021

Abstract

This study is to simulate the damage of layered shale under ultrasonic vibration with different bedding dip angles by establishing a discrete element model of layered shale with numerical simulation methods so as to explore the feasibility of ultrasonic vibration-assisted shale reservoir stimulation. The results show that the angle between the vibration direction and the bedding surface has a significant influence on the propagation of ultrasonic vibration.The smaller the angle, the more microcracks generated.The racks are mainly concentrated near the vibration stress, and fewer microcracks are generated in areas further away from the vibration source.Ultrasonic vibration has an obvious impact on the strength of layered shale, inducing a large number of microcracks inside the shale, and the change of microstructure and physical properties of the shale, also the uniaxial compressive strength and elastic modulus are significantly reduced. This study provides a theoretical basis for reservoir stimulation of layered shale using ultrasonic vibration.

Key words： layered shale; ultrasonic vibration; uniaxial compressive strength; numerical simulation; discrete element model

参考文献

[1] 邹才能,赵群,丛连铸,等.中国页岩气开发进展、潜力及前景[J].天然气工业,2021,41(1):1-14.
ZOU Caineng,ZHAO Qun,CONG Lianzhu,et al.Development progress, potential, and prospect of shale gas in China[J].Natural Gas Industry,2021,41(1):1-14.
[2] 丁乙,刘向君,罗平亚.裂缝性储层射孔井起裂压力影响因素分析[J].应用数学和力学,2018,39(7):811-820.
DING Yi,LIU Xiangjun,LUO Pingya.Analysis of factors influencing fracturing pressure of perforated wells in fractured reservoirs[J].Applied Mathematics and Mechanics,2018,39(7):811-820.
[3] 刘扬,狄鹏,高志勇,等.大功率超声波解堵工艺技术及其应用[J].河南石油,2006,20(2):81-82.
LIU Yang,DI Peng,GAO Zhiyong,et al.Technology and application of high-power ultrasonic unblock process[J].Henan Petroleum,2006,20(2):81-82.
[4] 张永发,祝济之,胡长华.超声波地层解堵机理研究初步[J].北京理工大学学报,2006,26(5):397-400.
ZHANG Yongfa,ZHU Jizhi,HU Changhua.Preliminary study on the mechanism of removal of bridge formation by ultrasonic waves[J].Transactions of Beijing Institute of Technology,2006,26(5):397-400.
[5] 任伟杰,袁旭东,潘一山.功率超声对煤岩力学性质影响的实验研究[J].辽宁工程技术大学学报(自然科学版),2001,20(6):773-776.
REN Weijie,YUAN Xudong,PAN Yishan.Experimental study on the influence of power ultrasound on mechanical properties of coal rock[J].Journal of Liaoning Technical University(Natural science),2001,20(6):773-776.
[6] 周喻,李程,王文林,等.单轴压缩条件下含层理煤岩力学特性的细观研究[J].中南大学学报(自然科学版),2022,53(10):4036-4047.
ZHOU Yu, LI Cheng,WANG Wenlin,et al.Microscopic study on mechanical properties of bedding coal rock under uniaxial compression conditions[J].Journal of Central South University (Science and Technology),2022,53(10):4036-4047.
[7] 孙仁远,王连保,彭秀君,等.稠油超声波降黏实验研究[J].油气田地面工程,2001,29(5):22-23.
SUN Renyuan,WANG Lianbao,PENG Xiujun,et al.Experimental study on heavy oil viscosity reduction by ultrasonic waves[J].Oil-Gasfield Surface Engineering,2001,29(5):22-23.
[8] 蒲春生,石道涵,赵树山,等.大功率超声波近井处理无机垢堵塞技术[J].石油勘探与开发,2011,38(2):243-248.
PU Chunsheng,SHI Daohan,ZHAO Shushan,et al.Technology of removing near wellbore inorganic scale damage by high power ultrasonic treatment[J].Petroleum Exploration and Development,2011,38(2):243-248.
[9] 尤诚程.浅析超声波采油技术应用现状及前景[J].科技展望,2016,26(18):166.
YOU Chengcheng.Brief analysis of the current situation and prospects of ultrasonic oil recovery technology application[J].Science and Technology Outlook,2016,26(18):166.
[10] 韩君鹏,赵大军,张书磊,等.基于离散元的超声波振动辅助TBM滚刀碎岩分析[J].钻探工程,2021,48(3):46-55.
HAN Junpeng,ZHAO Dajun,ZHANG Shulei,et al.Analysis of rock crushing by TBM roller based on discrete element method assisted by ultrasonic vibration[J].Drilling Engineering,2021,48(3):46-55.
[11] 时贤,程远方,蒋恕,等.页岩微观结构及岩石力学特征实验研究[J].岩石力学与工程学报,2014,33(增刊2):3439-3445.
SHI Xian,CHENG Yuanfang,JIANG Shu,et al.Experimental Study on microstructure and mechanical characteristics of shale[J].Chinese Journal of Rock Mechanics and Engineering,2014, 33(S2):3439-3445.
[12] 梁利喜,黄静,刘向君,等.天然裂缝对页岩储层网状诱导缝的控制作用[J].成都理工大学学报(自然科学版),2016,43(6):696-702.
LIANG Lixi,HUANG Jing,LIU Xiangjun,et al.Formation and controlling effect of natural fractures on network induced fractures in shale reservoir[J].Journal of Chengdu University of Technology(Science & Technology Edition),2016,43(6):696-702.
[13] 赵圣贤,夏自强,刘文平,等.四川盆地南部泸203 井区五峰组—龙马溪组页岩裂缝特征及形成演化[J].油气地质与采收率,2022,29(5):28-38.
ZHAO Shengxian,XIA Ziqiang,LIU Wenping,et al.Fracture characteristics and evolution of Wufeng-Longmaxi Formation shale in Lu 203 Well Area in southern Sichuan Basin[J].Petroleum Geology & Recovery Efficiency,2022,29(5):28-38.
[14] 张翼飞,杨勇,孙志刚,等.低渗透油藏压驱物理模拟与裂缝定量表征[J].油气地质与采收率,2022,29(4):143-149.
ZHANG Yifei,YANG Yong,SUN Zhigang,et al.Physical simulation of fracturing-flooding and quantitative characterization of fractures in low-permeability oil reservoirs[J].Petroleum Geology & Recovery Efficiency,2022,29(4):143-149.
[15] 但玲玲,史长林,文佳涛,等.多信息融合裂缝建模技术在碳酸盐岩双重介质油藏开发中的应用[J].油气地质与采收率,2022,29(1):46-52.
DAN Lingling,SHI Changlin,WEN Jiatao,et al.Application of multi-information fusion modeling technology for fractures in dual-medium carbonate reservoir[J].Petroleum Geology and Recovery Efficiency,2022,29(1):46-52.
[16] 高宇慧,李思远,巴忠臣,等.准噶尔盆地红172井区石炭系火山岩储层裂缝特征及定量预测[J].大庆石油地质与开发,2021,40(2):30-41.
GAO Yuhui,LI Siyuan,BA Zhongchen,et al.Characteristics and quantitative prediction of Carboniferous volcanic reservoir fractures in Well Block Hong-172 of Junggar Basin[J].Petroleum Geology & Oilfield Development in Daqing,2021,40(2):30-41.
[17] 任岚,林辰,林然,等.复杂裂缝中低密度支撑剂铺置数值模拟[J].大庆石油地质与开发,2021,40(6):52-61.
REN Lan,LIN Chen,LIN Ran,et al.Numerical simulation of the low-density proppant placement in complex fractures[J].Petroleum Geology & Oilfield Development in Daqing,2021,40(6):52-61.
[18] 田涛,李少轩,高阳,等.变质岩潜山裂缝型储层精细预测技术[J].石油地质与工程,2022,36(6):8-13.
TIAN Tao,LI Shaoxuan,GAO Yang,et al.Fine prediction technology of fractured reservoir in metamorphic buried hill[J].Petroleum Geology & Engineering,2022,36(6):8-13.

Options

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract

参考文献