复杂小断块油藏水驱辅助注气吞吐提高采收率研究

doi:10.3969/j.issn.1006-6535.2021.04.016

摘要/Abstract

摘要： 复杂小断块油藏单纯利用注水或注气措施难以兼顾整个剩余油区域,挖潜效果有限。为提高复杂小断块油藏高含水期剩余油采收率,运用数值模拟方法探索了水驱辅助注气吞吐的开发方式,同时利用经济和效率双重指标分析了其油藏适应性。依据不同措施方案下典型模型的开发效果,确定了该方法的最优开发模式为:补充能量—闷井增能—闷井阶段—开发阶段,进一步确定了其技术界限:气水注入速度比为6.5~8.5、阶段二与阶段一增压比为0.1~0.3、注采比为0.4~0.6。将研究成果应用于胜利油田a-7区块,模拟预测表明该方法相比基础水驱开发采收率提高12.96个百分点。研究成果对复杂小断块油藏高含水期调整开发措施、提高采收率具有重要的指导意义。

关键词: 水驱辅助注气吞吐, 提高采收率, 人工气顶, 数值模拟, 复杂小断块油藏, 胜利油田

Abstract: In complex reservoir with small fault block, water or gas injection is difficultly to be applied to the whole reservoir and has little effect on the further developing the remaining oil. In order to improve the recovery efficiency of remaining oil in the complex reservoir with small fault block during the high water cut stage, numerical simulation methods were employed to explore the gas-injection stimulation assisted by water flooding, and its reservoir adaptability was analyzed by economic and efficiency indicators. According to the development effect of typical models under different measures, the optimal development mode of this method was determined as follows: energy supplement-energy enhancement bu well shut-in-shut-in stage-development stage; its technical limits were further determined as follows: the ratio of gas and water injection rates was 6.5 to 8.5, the pressure ratio between Stage 2 to Stage 1 was 0.1 to 0.3, and the injection-production ratio was 0.4 to 0.6. The study results were applied to Block A-7 of Shengli Oilfield, and the simulation prediction showed that this method improved the oil recovery by 12.96 percentage points compared with basic water-flooding development. The study results play an important guiding role in the development measure adjustment and oil recovery enhancement in complex reservoir with small fault block during the high water cut stage.

Key words: gas-injection stimulation assisted by water flooding, oil recovery enhancement, artificial gas cap, numerical simulation, complex reservoir with small fault block, Shengli Oilfield

中图分类号:

TE347

曲世元, 姜汉桥, 李俊键, 周宇, 马康, 常元昊. 复杂小断块油藏水驱辅助注气吞吐提高采收率研究[J]. 特种油气藏, 2021, 28(4): 116-122.

Qu Shiyuan, Jiang Hanqiao, Li Junjian, Zhou Yu, Ma Kang, Chang Yuanhao. Study on Oil Recovery Enhancement by Gas-Injection Stimulation Assisted by Water Flooding in Complex Reservoir with Small Fault Block[J]. Special Oil & Gas Reservoirs, 2021, 28(4): 116-122.

参考文献

[1] 吴英,刘汝敏,刘子雄.复杂小断块油藏不补充能量提高采收率方法[J].吐哈油气,2012,17(1):51-53.
WU Ying,LIU Rumin,LIU Zixiong.Enhancing recovery method in complicated block fault reservoir with less well and no supplementary energy[J].Tuha Oil and Gas,2012,17(1):51-53.
[2] 高华娟,李家玮,张荻楠.海拉尔塔木察格盆地复杂断块油藏精细油层对比及沉积特征分析[J].东北石油大学学报,2018,42(4):40-51.
GAO Huajuan,LI Jiawei,ZHANG Dinan.Analysis of fine oil reservoir correlation and sedimentary characteristics of complex fault block reservoirs in Hailer Tamtsag Basin[J].Journal of Northeast Petroleum University,2018,42(4):40-51.
[3] JIANG S, WANG W, ZHANG A, et al.Genetic mechanism and evolution of the covert fault zone and its oil-controlling mode in Qikou Sag,eastern China[J].Energies,2019,12(1):98.
[4] 宋宝权,沙宗伦,毛伟.复杂断块油田精细油藏描述与滚动开发实践——以塔木察格油田为例[J].大庆石油地质与开发,2019,38(5):222-231.
SONG Baoquan,SHA Zonglun,MAO Wei.Fine reservoir description and progressive development practice of the complex fault-block oilfield:taking tamutsag Oilfield as an example[J].Petroleum Geology & Oilfield Development in Daqing,2019,38(5):222-231.
[5] YUAN S, WANG Q.New progress and prospect of oilfields development technologies in China[J].Petroleum Exploration and Development,2018,45(4):698-711.
[6] 马康,姜汉桥,李俊键,等.基于核磁共振的复杂断块油藏微观动用均衡程度实验[J].断块油气田,2016,23(6):745-748.
MA Kang,JIANG Hanqiao,LI Junjian,et al.Experimental study on micro balanced development of complex fault-block reservoirs based on nuclear magnetic resonance[J].Fault-Block Oil & Gas Field,2016,23(6):745-748.
[7] 姜兰兰.注水开发工艺技术应用分析[J].科学技术与工程,2011,11(33):8321-8324,8330.
JIANG Lanlan.Water flooding technology and its application analysis[J].Science Technology and Engineering,2011,11(33):8321-8324,8330.
[8] 李涤淑,宋先保,刘秀珍,等.CO₂单井吞吐矿场试验[J].国外油田工程,2004,20(3):40-41.
LI Dishu,SONG Xianbao,LIU Xiuzhen,et al.Field test of cyclic CO₂ stimulation in single well[J].Foreign Oilfield Engineering,2004,20(3):40-41.
[9] 张国强,孙雷,吴应川,等.小断块油藏CO₂、N₂单井吞吐强化采油可行性对比研究[J].钻采工艺,2008,31(4):53-55,73.
ZHANG Guoqiang,SUN Lei,WU Yingchuan,et al.Feasibility study on single well CO₂,N₂ huff and puff in small fault block reservoir[J].Drilling & Production Technology,2008,31(4):53-55,73.
[10] 张国强,孙雷,孙良田,等.小断块油藏单井CO₂吞吐强化采油注气时机及周期注入量优选[J].特种油气藏,2007,14(1):69-72,79.
ZHANG Guoqiang,SUN Lei,SUN Liangtian,et al.Optimization of single well CO₂ injection occasion and cyclic injection rate in small fault block reservoir[J].Special Oil & Gas Reservoirs,2007,14(1):69-72,79.
[11] CAUDLE B H, DYES A B.Improving miscible displacement by gas-water injection[J].Transactions of the AIME,1958,213(1):281-283.
[12] RAIMONDI P, TORCASO M A.Mass transfer between phases in a porous medium: a study of equilibrium[J].Society of Petroleum Engineers Journal,1965,5(1):51-59.
[13] 郭平,张陈珺,熊健.气体辅助重力驱油(GAGD)研究进展[J].科学技术与工程, 2015,15(5):176-184.
GUO Ping,ZHANG Chenjun,XIONG Jian.Present state of gas-assisted gravity drainage[J].Science Technology and Engineering,2015,15(5):176-184.
[14] 王小玉,张智君.利用灰色关联度分析底水油藏水平井含水率变化规律[J].新疆石油科技,2014,24(4):13-16.
WANG Xiaoyu,ZHANG Zhijun.Analysis of water content variation law of horizontal wells in bottom water reservoirs with grey relational degree[J].Xinjiang Petroleum Science & Technology,2014,24(4):13-16.
[15] BATILL S M,STELMACK M A.Frame work for multidisciplinary design based on response-surface approximations[J].Journal of Aircraft,1999,36(1):34-38.
[16] 熊钰,钟浩,周文胜,等.三维大尺度非均质油藏模型下的剩余油水驱物理模拟实验研究[J]. 油气藏评价与开发, 2019, 9(6): 16-23.
XIONG Yu, ZHONG Hao,ZHOU Wensheng,et al.Water driving physical simulation test of remaining oil based on 3D large-scale heterogeneous reservoir model[J]. Reservoir Evaluation and Development,2019,9(6):16-23.
[17] 杨志军,杜旭林,曹仁义,等.复杂小断块采收率及经济合理井网密度模型[J].断块油气田,2020,27(1):80-84.
YANG Zhijun,DU Xulin,CAO Renyi,et al.Recovery ratio of complex small fault blocks and economic reasonable well pattern density model[J].Fault-Block Oil & Gas Field,2020,27(1):80-84.
[18] 周宗良,蔡明俊,张凡磊,等.高含水油藏多介质驱替剩余油赋存状态与时移特征[J].断块油气田,2020,27(5):608-612.
ZHOU Zongliang,CAI Mingjun,ZHANG Fanlei,et al.Residual oil occurrence state and time-shift characteristics of multi-media displacement of high water-cut reservoirs[J].Fault-Block Oil & Gas Field,2020,27(5):608-612.
[19] 王智林,林波,葛永涛,等.低渗油藏水驱后注CO₂补充能量机理及方式优化[J].断块油气田,2019,26(2):231-235.
WANG Zhilin,LIN Bo,GE Yongtao,et al.Mechanisms and optimization of supplementing in-situ energy by CO₂ injection after water flooding in low permeability reservoirs[J].Fault-Block Oil & Gas Field,2019,26(2):231-235.
[20] 张磊,贾兰,张道连.强边水小断块油藏聚驱后期开发技术对策研究[J].油气藏评价与开发,2020,10(6):72-77.
ZHANG Lei, JIA Lan, ZHANG Daolian.Developing technical countermeasures in the late stage of polymer flooding in small fault block reservoirs with strong edge water[J].Reservoir Evaluation and Development,2020,10(6):72-77.
[21] 雷霄,张乔良,罗吉会,等.涠西南油田群复杂断块油藏水驱剩余油精细表征技术及其现场应用[J].中国海上油气,2015,27(4):80-85,92.
LEI Xiao,ZHANG Qiaoliang,LUO Jihui,et al.Fine characterization technique of remaining oil after water flooding for complex fault block reservoirs in Weizhou Oilfields and its application[J].China Offshore Oil & Gas,2015,27(4):80-85,92.
[22] 冯其红,王波,王相,等.基于油藏流场强度的井网优化方法研究[J].西南石油大学学报(自然科学版),2015,37(4):181-186.
FENG Qihong,WANG Bo,WANG Xiang,et al.Optimization of well patterns based on flow field intensity[J].Journal of Southwest Petroleum University(Science & Technology Edition),2015,37(4):181-186.
[23] 崔传智,尹帆,李立峰,等.水驱油藏产量递减评价方法[J].断块油气田,2019,26(5):605-608.
CUI Chuanzhi,YIN Fan,LI Lifeng,et al.Evaluation method of production decline for water drive reservoir[J].Fault-Block Oil & Gas Field,2019,26(5):605-608.