静态与动态渗吸相结合提高致密砂岩开发效果实验

doi:10.3969/j.issn.1006-6535.2025.05.015

摘要/Abstract

摘要： 针对静态、动态渗吸对致密砂岩微观孔隙的动用特征及协同机制不明确等问题,采用核磁共振测试技术,开展静态和动态岩心渗吸实验,在分析岩心渗吸前后T₂谱的基础上,研究了2种渗吸方式对微小孔隙和大孔隙的渗吸动用特征,评价了渗吸时间、界面张力和渗透率对渗吸效果的影响,提出了先静后动联合渗吸的新方法。实验结果表明:静态渗吸中微小孔隙(孔径为0.002 7～0.368 0 μm)采出程度高于大孔隙(孔径为0.368 0～23.000 0 μm),动用比例占58.7%以上,微小孔隙采出程度随渗透率的增加而提高,随界面张力的降低先提高后降低;动态渗吸中大孔隙采出程度高于微小孔隙,是总采收率的主要贡献者,随着界面张力的降低,大孔隙采出程度提高,微小孔隙和总孔隙采出程度先提高后降低,动态渗吸的最佳界面张力低于静态渗吸的最佳界面张力;先静后动的联合渗吸方式能够同时大幅提高微小孔隙和大孔隙采出程度。实践表明,先导试验井组首轮静动联合渗吸后,日均产油量增幅达336%,平均含水率降幅达29%,增油控水效果显著。该研究对提高致密油采收率具有较强的指导意义。

关键词: 致密砂岩, 静态渗吸, 动态渗吸, 核磁共振, 微观孔隙, 界面张力

Abstract: In response to the unclear production characteristics and synergistic mechanisms of static and dynamic imbibition on micro-pores,nuclear magnetic resonance (NMR) testing technology was employed to conduct static and dynamic core imbibition experiments.Based on the analysis of T₂ spectra before and after core imbibition,the production characteristics of the two imbibition methods on small pores and large pores were studied,the effects of imbibition time,interfacial tension,and permeability on imbibition efficiency were evaluated,and a new method of combined imbibition,static first followed by dynamic,was proposed.The experimental results show that in static imbibition,the recovery degree of small pores (pore diameter:0.002 7-0.368 0 μm) is higher than that of large pores (pore diameter:0.368 0-23.000 0 μm),accounting for more than 58.7% of the produced proportion.The recovery degree of small pores increases with increasing permeability and first increases then decreases with decreasing interfacial tension.In dynamic imbibition,the recovery degree of large pores is higher than that of small pores and is the main contributor to the total recovery factor.With decreasing interfacial tension,the recovery degree of large pores increases,while that of small pores and total pores first increases then decreases.The optimal interfacial tension for dynamic imbibition is lower than that for static imbibition.The combined imbibition method,static first followed by dynamic,can simultaneously and significantly improve the recovery degree of both small and large pores.Practice shows that after the first round of combined static-dynamic imbibition in the pilot test well group,the average daily oil production increase reached 336%,and the average water cut decrease reached 29%,demonstrating significant oil increase and water control effects.This research has strong guiding significance for improving tight oil recovery.

Key words: tight sandstone, static imbibition, dynamic imbibition, nuclear magnetic resonance, micro-pores, interfacial tension

中图分类号:

TE341

魏长霖, 郝红勋, 赵钰峰, 李康, 史海峰, 张春晖. 静态与动态渗吸相结合提高致密砂岩开发效果实验[J]. 特种油气藏, 2024, 32(5): 129-136.

WEI Changlin, HAO Hongxun, ZHAO Yufeng, LI Kang, SHI Haifeng, ZHANG Chunhui. Experiment on improving tight sandstone development by combining static and dynamic imbibition[J]. Special Oil & Gas Reservoirs, 2024, 32(5): 129-136.

参考文献

[1] 黄兴,李天太,王香增,等.致密砂岩储层可动流体分布特征及其影响因素——以鄂尔多斯盆地姬塬油田延长组长8储层为例[J].石油学报,2019,40(5):557-567.
HUANG Xing,LI Tiantai,WANG Xiangzeng,et al.Distribution characteristics and its influence factors of movable fluid in tight sandstone reservoir:a case study from Chang 8 Reservoir of Yanchang Formation in Jiyuan Oilfield,Ordos Basin[J].Acta Petrolei Sinica,2019,40(5):557-567.
[2] 蒋天昊,宋方新,邓宝康,等.鄂尔多斯盆地吴起油田长6油层组沉积微相特征及其对储层的控制[J].西北地质,2020,53(4):130-139.
JIANG Tianhao,SONG Fangxin,DENG Baokang,et al.Sedimentary microfacies of Chang 6 oil-bearing formation and its control on reservoir in Wuqi Oilfield,Ordos Basin[J].Northwestern Geology,2020,53(4):130-139.
[3] 张建中,高树生,熊伟,等.基于致密砂岩储层气水渗流阻力系数的产能新模型[J].天然气工业,2023,43(1):177-187.
ZHANG Jianzhong,GAO Shusheng,XIONG Wei,et al.A new productivity model based on gas-water seepage resistance coefficient for tight sandstone reservoirs[J].Natural Gas Industry,2023,43(1):177-187.
[4] 吴小斌,杜支文,强小龙,等.鄂尔多斯盆地长7段致密砂岩二元孔隙结构及分形特征[J].油气地质与采收率,2024,31(6):45-56.
WU Xiaobin,DU Zhiwen,QIANG Xiaolong,et al.Binary pore structure and fractal characteristics of tight sandstone:a case study of Chang 7 Member of Triassic Yanchang Formation in Ordos Basin[J].Petroleum Geology and Recovery Efficiency,2024,31(6):45-56.
[5] 李爱芬,何冰清,雷启鸿,等.界面张力对低渗亲水储层自发渗吸的影响[J].中国石油大学学报(自然科学版),2018,42(4):67-74.
LI Aifen,HE Bingqing,LEI Qihong,et al.Influence of interfacial tension on spontaneous imbibition in low-permeability water-wet reservoirs[J].Journal of China University of Petroleum(Edition of Natural Sciences),2018,42(4):67-74.
[6] MIRZAEI P A.Analysis of counter-current spontaneous imbibition in presence of resistive gravity forces:displacement characteristics and scaling[J].Journal of Unconventional Oil ＆ Gas Resources,2015,12(671):68-86.
[7] AKBARABADI M,SARAJI S,PIRI M,et al.Nano-scale experimental investigation of in-situ wettability and spontaneous imbibition in ultratight reservoir rocks[J].Advances in Water Resources,2017,107(4):160-179.
[8] 李晓骁,任晓娟,罗向荣.低渗透致密砂岩储层孔隙结构对渗吸特征的影响[J].油气地质与采收率,2018,25(4):119-124.
LI Xiaoxiao,REN Xiaojuan,LUO Xiangrong.Influence of pore structures on the characteristic of spontaneous imbibition in low-permeability tight sandstone reservoir[J].Petroleum Geology and Recovery Efficiency,2018,25(4):119-124.
[9] WANG L,ZHANG Y F,ZOU R,et al.Molecular dynamics investigation of DME assisted CO₂ injection to enhance shale oil recovery in inorganic nanopores.Journal of Molecular Liquids,2023,385(2):122-138.
[10] 胡伟.水驱油藏注气驱油机理及渗流规律研究[D].北京:中国石油大学(北京),2018.
HU Wei.Mechanisms of gas flooding for enhanced oil recovery and seepage behavior in water-flooded reservoirs[D].Beijing:China University of Petroleum(Beijing),2018.
[11] 袁帅,周福建,李源,等.致密砂岩油藏纳米乳液渗吸增产作用机理[J].油气地质与采收率,2024,31(1):126-136.
YUAN Shuai,ZHOU Fujian,LI Yuan,et al.Mechanism of imbibition and production enhancement of nanoemulsion in tight sandstone oil reservoirs[J].Petroleum Geology and Recovery Efficiency,2024,31(1):126-136.
[12] 高涛,王香增,王锰,等.基于随机变径毛细管束模型的渗吸-驱替机理分析[J].油气地质与采收率,2023,30(5):100-109.
GAO Tao,WANG Xiangzeng,WANG Meng,et al.Analysis of imbibition-displacement mechanism based on random variable-diameter capillary bundle model[J].Petroleum Geology and Recovery Efficiency,2023,30(5):100-109.
[13] SHARMA J,INWOOD S B,KOVSCEK A R.Experiments and analysis of multiscale viscous fingering during forced imbibition [J].SPE Journal,2012,17(4):1142-1159.
[14] CHEN Ting,YANG Zhengming,DING Yunhong,et al.Waterflooding huff-n-puff in tight oil cores using online nuclear magnetic resonance [J].Energies,2018,11(6):1524.
[15] 国家能源局.岩样核磁共振参数实验室测量规范:SY/T 6490—2014[S].北京:石油工业出版社,2015:3-5.
National Energy Administration.Laboratory measurement specifications for rock sample NMR parameters:SY/T 6490-2014[S].Beijing:Petroleum Industry Press,2015:3-5.
[16] WANG Y,LIU L,LI S,et al.The forming mechanism and process of tight oil sand reservoirs:a case study of Chang 8 oil layers of the Upper Triassic Yanchang Formation in the western Jiyuan Area of the Ordos Basin,China[J].Journal of Petroleum Science and Engineering,2017,158(6):29-46.
[17] DAI Caili,CHENG Rui,SUN Xin,et al.Oil migration in nanometer to micrometer sized pores of tight oil sandstone during dynamic surfactant imbibition with online NMR[J].Fuel,2019,245(3):544-553.
[18] 闫健,秦大鹏,王平平,等.鄂尔多斯盆地致密砂岩储层可动流体赋存特征及其影响因素[J].油气地质与采收率,2020,27(6):47-56.
YAN Jian,QIN Dapeng,WANG Pingping,et al.Occurrence characteristics and main controlling factors of movable fluid in tight sandstone reservoirs in Ordos Basin[J].Petroleum Geology and Recovery Efficiency,2020,27(6):47-56.
[19] 郎东江,伦增珉,吕成远,等.页岩油注二氧化碳提高采收率影响因素核磁共振实验[J].石油勘探与开发,2021,48(3):1-10.
LANG Dongjiang,LUN Zengmin,LYU Chengyuan,et al.Nuclear magnetic resonance experimental study of CO₂ injection to enhance shale oil recovery[J].Petroleum Exploration and Development,2021,48(3):1-10.
[20] 黄兴,李响,张益,等.页岩油储集层二氧化碳吞吐纳米孔隙原油微观动用特征[J].石油勘探与开发,2022,49(3):557-564.
HUANG Xing,LI Xiang,ZHANG Yi,et al.Microscopic production characteristics of crude oil in nano-pores of shale oil reservoirs during CO₂ huff and puff[J].Petroleum Exploration and Development,2022,49(3):557-564.
[21] 王敉邦,杨胜来,吴润桐,等.致密油藏渗吸采油影响因素及作用机理[J].大庆石油地质与开发,2018,37(6):158-163.
WANG Mibang,YANG Shenglai,WU Runtong,et al.Influencing factors and mechanism of the imbibition production in tight oil reservoirs[J].Petroleum Geology & Oilfield Development in Daqing,2018,37(6):158-163.