天然气水合物注热分解诱发储层变形破坏的正交数值模拟研究

doi:10.3969/j.issn.1006-6535.2024.02.013

特种油气藏 ›› 2024, Vol. 31 ›› Issue (2): 112-119.DOI: 10.3969/j.issn.1006-6535.2024.02.013

天然气水合物注热分解诱发储层变形破坏的正交数值模拟研究

翟诚^1,2, 吴迪³, 秦冬冬^1,2

1.山西工程技术学院,山西阳泉 045000;
2.山西工程技术学院矿区生态修复与固废资源化省市共建山西省重点实验室培育基地,山西阳泉 045000;
3.辽宁工程技术大学,辽宁阜新 123000

收稿日期:2022-10-24 修回日期:2024-01-20 出版日期:2024-04-25 发布日期:2024-07-26
通讯作者: 吴迪(1981—),男,教授,2003年毕业于沈阳农业大学水利水电工程专业,2013年毕业于辽宁工程技术大学工程力学专业,获博士学位,现主要从事渗流力学及应用方面的教学与科研工作。
作者简介:翟诚(1981—),男,副教授,2005年毕业于辽宁工程技术大学理论与应用力学专业,2018年毕业于该校工程力学专业,获博士学位,现主要从事天然气水合物开采方面的研究工作。
基金资助:
国家自然科学基金“压裂页岩吸附超临界CO₂驱替CH₄渗流与损伤耦合机理研究”(51974147)、“新疆缓斜巨厚煤层季节性地表水保护开采研究”(52104140);山西工程技术学院教师科研启动基金“THM耦合作用下天然气水合物分解诱发储层变形破坏的机理研究”(2021QD-02);2021年第二批博士毕业生、博士后研究人员来晋工作奖励经费项目“THM耦合作用下天然气水合物分解诱发储层变形破坏的机理研究”(2021PT-13)

Qrthogonal Numerical Simulation Study of the Reservoir Deformation Damage Induced by the Thermal Injection Decomposition of Natural Gas Hydrate

Zhai Cheng^1,2, Wu Di³, Qin Dongdong^1,2

1. Shanxi Institute of Technology, Yangquan, Shanxi 045000, China;
2. The Provincial and Municipal Key Laboratory Cultivation Base of Shanxi Province for Ecological Rehabilitation of Mining Areas and Solid Waste Resource Utilization, Shanxi Institute of Technology, Yangquan, Shanxi 045000, China;
3. Liaoning Technical University, Fuxin, Liaoning 123000, China

Received:2022-10-24 Revised:2024-01-20 Online:2024-04-25 Published:2024-07-26

摘要/Abstract

摘要： 针对天然气水合物热分解而引起的储层失稳破坏机理及影响因素不明确的问题,考虑因水合物热分解引起的地层传热、孔隙流体渗流和固体骨架的变形破坏,建立了水合物沉积层的热-流-固耦合模型及其作用下储层固体骨架的弹塑性本构模型。基于ABAQUS软件的USDFLD子程序进行二次开发,开展正交实验数值模拟,分析注热温度差、水合物沉积层的绝对渗透率和有效主应力差对水合物沉积层近井储层变形破坏影响的敏感性及影响机理。结果表明:对近井储层变形破坏影响的敏感程度由大到小依次为有效主应力差、绝对渗透率、注热温度差;水合物热分解引起的近井储层力学性质劣化和有效应力下降是导致其发生变形破坏的主要原因;有效主应力差越大,等效塑性应变最大值越大,并且受水平地应力非均匀性的影响,近井储层变形破坏最严重的位置始终位于井眼最小水平地应力方向上。该研究成果可为热激法开采天然气水合物或含水合物地层的钻井作业提供借鉴。

关键词: 天然气水合物, 注热分解, 热-流-固耦合模型, 弹塑性本构模型, 正交数值模拟, 等效塑性应变最大值

Abstract: In response to the problem that the damage mechanism and influencing factors of the reservoir destabilization caused by the thermal decomposition of natural gas hydrate are not clear, the coupled heat-fluid-solid model of the hydrate deposition layer and the elastic-plasticity intrinsic model of the solid skeleton of the reservoir under the action of such coupled model have been established in consideration of the formation heat transfer, pore fluid seepage and deformation damage of solid skeleton due to the thermal decomposition of hydrate. Based on the secondary development of the USDFLD subroutine of ABAQUS software, the orthogonal numerical simulation experiments were carried out to analyze the sensitivity of the thermal injection temperature difference, the absolute permeability of the hydrate deposition layer, and the effective principal stress difference to the influence of the deformation damage of near-well reservoir in the the hydrate deposition layer and the influence mechanism. The results show that the sensitivity to the influence of the deformation damage of near-well reservoir is in descending order of the effective principal stress difference, absolute permeability, and thermal injection temperature difference; the deterioration of the mechanical properties of the near-well reservoir and the decrease of the effective stress caused by the thermal decomposition of hydrate are the main reasons for the deformation damage; the larger the effective principal stress difference is, the larger the maximum value of the equivalent plastic strain is, and the location of the most severe deformation damage in the near-well reservoir is always located in the direction of the minimum horizontal geostress in the borehole under the influence of the the non-uniformity of the horizontal geostress. This study provides a reference for the natural gas hydrate extraction with the thermal stimulation method and drilling operations of hydrate-bearing formations.

Key words: natural gas hydrate, thermal injection decomposition, thermo-hydro-mechanical coupled model, elasto-plastic constitutive model, orthogonal numerical simulation, maximum equivalent plastic strain

中图分类号:

TE319

翟诚, 吴迪, 秦冬冬. 天然气水合物注热分解诱发储层变形破坏的正交数值模拟研究[J]. 特种油气藏, 2024, 31(2): 112-119.

Zhai Cheng, Wu Di, Qin Dongdong. Qrthogonal Numerical Simulation Study of the Reservoir Deformation Damage Induced by the Thermal Injection Decomposition of Natural Gas Hydrate[J]. Special Oil & Gas Reservoirs, 2024, 31(2): 112-119.

参考文献

[1] 张旭辉,鲁晓兵,刘乐乐.天然气水合物开采方法研究进展[J].地球物理学进展,2014,29(2):858-869.
ZHANG Xuhui,LU Xiaobing,LIU Lele.Research progress in development methods of natural gas hydrate[J].Progress in Geophysics,2014,29(2):858-869.
[2] 郑明明,王晓宇,周珂锐,等.深水油气固井水合物储层物性响应与高压气水反侵研究[J].煤田地质与勘探,2021,49(3):118-127.
ZHENG Mingming,WANG Xiaoyu,ZHOU Kerui,et al.Hydrate reservoir physical properties response and high-pressure gas-water reverse penetration during deepwater oil and gas cementing[J].Coal Geology & Exploration,2021,49(3):118-127.
[3] 宫智武,张亮,程海清,等.海底天然气水合物分解对海洋钻井安全的影响[J].石油钻探技术,2015,43(4):19-24.
GONG Zhiwu,ZHANG Liang,CHENG Haiqing,et al.The influence of subsea natural gas hydrate dissociation on the safety of offshore drilling[J].Petroleum Drilling Techniques,2015,43(4):19-24.
[4] LI Xinpo,HE Siming.Progress in stability analysis of submarine slopes considering dissociation of gas hydrates[J].Environmental Earth Sciences,2012,66(3):741-747.
[5] NIAN T K,SONG X L,ZHAO W,et al.Submarine slope failure due to overpressure fluid associated with gas hydrate dissociation[J].Environmental Geotechnics,2022,9(2):108-123.
[6] 唐常锐,徐秀刚,孙秉才,等.天然气水合物分解诱发海底滑坡影响因素分析及致灾风险评价[J].海洋地质前沿,2021,37(5):14-21.
TANG Changrui,XU Xiugang,SUN Bingcai,et al.Influence factors and risk assessment for seabed land-slides induced by natural gas hydrate decomposition[J].Marine Geology Frontiers,2021,37(5):14-21.
[7] 唐瑞玲,孙忠军,张富贵.天然气水合物勘查技术及环境效应研究进展[J].岩性油气藏,2011,23(4):20-34.
TANG Ruiling,SUN Zhongjun,ZHANG Fugui.Research progress in exploration technologies and environmental effects for gas hydrates[J].Lithologic Reservoirs,2011,23(4):20-34.
[8] 翁焕新,许赟溢,楼竹山,等.天然气水合物的稳定性及其环境效应[J].浙江大学学报(理学版),2006,33(5):588-594.
WENG Huanxin,XU Yunyi,LOU Zhushan,et al.Stability of natural gas hydrate and its environmental effect[J].Journal of Zhejiang University(Science Edition),2006,33(5):588-594.
[9] DANGAYACH S,SINGH D N,KUMAR P,et al.Thermal instability of gas hydrate bearing sediments:some issues[J].Marine and Petroleum Geology,2015,67:653-662.
[10] 谭富荣,耿庆明,刘世明,等.天然气水合含油气系统研究现状与展望[J].特种油气藏,2021,28(1):1-9.
TAN Furong,GENG Qingming,LIU Shiming,et al.Research status and prospect of natural gas hydrate petroleum system[J].Special Oil & Gas Reservoirs,2021,28(1):1-9.
[11] FREIJ-AYOUB R,TAN C,CLENNELLl B et al.A wellbore stability model for hydrate bearing sediments[J].Journal of Petroleum Science and Engineering,2007,57:209-220.
[12] KIMOTO S,OKA F,FUSHITA T,et al.A chemo-thermo-mechanically coupled numerical simulation of the deformation the subsurface ground deformation due to methane hydrate dissociation[J].Computers and Geotechnics,2007,34(4):216-228.
[13] KIMOTO S,OKA F,FUSHITA T.A chemo-thermo-mechanically coupled analysis of ground deformation induced by gas hydrate dissociation[J].International Journal of Mechanical Sciences,2010,52(2):365-376.
[14] ZHANG Xuhui,LU Xiaobing,LI Qingping,et al.Thermally induced evolution of phase transformations in gas hydrate sediment[J].Science China:Physics,Mechanics & Astronomy,2010,53(8):1530-1535.
[15] 张旭辉,鲁晓兵,李清平,等.水合物地层中考虑相变的轴对称热传导问题[J].地学前缘,2012,19(2):1-7.
ZHANG Xuhui,LU Xiaobing,LI Qingping,et al.Axial symmetrical thermal conduction of gas hydrate-bearing sediments related to phase transformations[J].Earth Science Frontiers,2012,19(2):1-7.
[16] 张旭辉,鲁晓兵.天然气水合物热分解引起多场响应的特征时间分析[J].力学与实践,2022,44(5):1105-1110.
ZHANG Xuhui,LU Xiaobing.The characteristic times of multi-field during gas hydrate thermal induced dissociation in stratum[J].Mechanics in Engineering,2022,44(5):1105-1110.
[17] 刘乐乐,鲁晓兵,张旭辉.天然气水合物分解区演化数值分析[J].石油学报,2014,35(5):941-951.
LIU Lele,LU Xiaobing,ZHANG Xuhui.Numerical analysis on evolution of natural gas hydrate decomposition region in hydrate-bearing sediment[J].Acta Petrolei Sinica,2014,35(5):941-951.
[18] 吴二林,魏厚振,颜荣涛,等.含天然气水合物沉积物分解过程的有限元模拟[J].岩土力学,2012,33(9):2811-2821.
WU Erlin,WEI Houzhen,YAN Rongtao,et al.FEM-based simulation of decomposition process of gas hydrate-bearing sediments[J].Rock and Soil Mechanics,2012,33(9):2811-2821.
[19] 李令东,程远方,梅伟,等.温度影响天然气水合物地层井壁稳定的有限元模拟[J].天然气工业,2012,32(8):74-78.
LI Lingdong,CHENG Yuanfang,MEI Wei,et al.Finite element simulation of temperature impact on wellbore stability of gas-hydrate-bearing sediments[J].Natural Gas Industry,2012,32(8):74-78.
[20] 孙可明,王婷婷,翟诚,等.天然气水合物加热分解储层变形破坏规律研究[J].特种油气藏,2017,24(5):91-96.
SUN Keming,WANG Tingting,ZHAI Cheng,et al.Patterns of reservoir deformation due to thermal decomposition of natural gas hydrates[J].Special Oil & Gas Reservoirs,2017,24(5):91-96.
[21] 孙可明,王婷婷,翟诚,等.不同饱和度天然气水合物加热分解界面变化规律[J].特种油气藏,2018,25(5):129-134.
SUN Keming,WANG Tingting,ZHAI Cheng,et al.Heating decomposition interface of natural gas hydrate with different saturations[J].Special Oil & Gas Reservoirs,2018,25(5):129-134.
[22] 翟诚,孙可明,辛利伟,等.天然气水合物注热开采近井储层变形破坏的数值模拟研究[J].地质力学学报,2017,23(6):821-828.
ZHAI Cheng,SUN Keming,XIN Liwei,et al.Numerical simulation research of deformation and fracture of the formation near the wellbore during the heat injection exploitation of natural gas hydrates[J].Journal of Geomechanics,2017,23(6):821-828.
[23] 朱渊,陈国明,张若昕.钻井液温度影响下天然气水合物井壁稳定性安全评估[J].安全与环境学报,2018,18(6):2130-2135.
ZHU Yuan,CHEN Guoming,ZHANG Ruoxin.Safety evaluation on the wellbore stability of the gas hydrate due to the temperature of drilling fluid[J].Journal of Safety and Environment,2018,18(6):2130-2135.
[24] 冯永昌,陈林,岡岛淳之介,等.天然气水合物藏裂缝注热的数值模拟研究[J].工程热物理学报,2021,42(3):663-667.
FENG Yongchang,CHEN Lin,OKAJIMA Junnosuke,et al.Numerical simulation study of heat injection into fractures in natural gas hydrate reservoirs[J].Journal of Engineering Thermophysics,2021,42(3):663-667.
[25] 李庆超,王威,王义顷,等.水合物储层钻井水合物分解及井眼坍塌分析[J].石油机械,2021,49(6):43-50.
LI Qingchao,WANG Wei,WANG Yiqing,et al.Hydrate dissociation and wellbore collapse analysis in hydrate reservoir drilling[J].China Petroleum Machinery,2021,49(6):43-50.
[26] KIM H C,BISHNOI P R,HEIDEMANN R A,et al.Kinetics of methane hydrate decomposition[J].Chemical Engineer Science,1987,42(7):1645-1653.
[27] YUN T S,SANTAMARINA J C,RUPPEL C.Mechanical properties of sand,silt,and clay containing tetrahydrofuran hydrate[J].Journal of Geophysical Research,2007,112(B04106):1-13.
[28] RUTQVIST J,MORIDIS G J,GROVER T,et al.Geomechanical response of permafrost-associated hydrate deposits to depressurization-induced gas production[J].Journal of Petroleum Science and Engineering,2009,67:1-12.
[29] 万义钊,吴能友,胡高伟,等.南海神狐海域天然气水合物降压开采过程中储层的稳定性[J].天然气工业,2018,38(4):117-128.
WAN Yizhao,WU Nengyou,HU Gaowei,et al.Reservoir stability in the process of natural gas hydrate production by depressurization in the Shenhu Area of the South China Sea[J].Natural Gas Industry,2018,38(4):117-128.

天然气水合物注热分解诱发储层变形破坏的正交数值模拟研究

Qrthogonal Numerical Simulation Study of the Reservoir Deformation Damage Induced by the Thermal Injection Decomposition of Natural Gas Hydrate

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 12

编辑推荐

Metrics

本文评价

[1]	孟大江, 路允乾, 张宝金, 王利杰. 叠前反演技术在天然气水合物储层预测中的应用[J]. 特种油气藏, 2023, 30(2): 51-57.
[2]	翟诚, 孙可明. 天然气水合物降压分解诱发储层变形破坏正交数值模拟实验研究[J]. 特种油气藏, 2022, 29(1): 99-106.
[3]	谭富荣, 耿庆明, 刘世明, 杜芳鹏, 刘志武. 天然气水合物含油气系统研究现状与展望`[J]. 特种油气藏, 2021, 28(1): 1-9.
[4]	孙可明，王婷婷，翟诚，辛利伟，范楠. 不同饱和度天然气水合物加热分解界面变化规律[J]. 特种油气藏, 2018, 25(5): 129-.
[5]	孙林，杨万有，李旭光，杨淼. 天然气水合物酸化-自生热气开采技术研究[J]. 特种油气藏, 2018, 25(3): 149-.
[6]	孙可明，王婷婷，翟诚，罗慧玉. 天然气水合物加热分解储层变形破坏规律研究[J]. 特种油气藏, 2017, 24(5): 91-.
[7]	邓磊，文志刚，刘蕴，董纹希. 漠河盆地漠河组天然气水合物潜在气源岩评价[J]. 特种油气藏, 2015, 22(5): 31-.
[8]	李芳芳刘晓栋. 天然气水合物开采新技术及其工业化开采的制约因素[J]. , 2010, 17(3): 1-.
[9]	邓柯　申艳　王宇. 天然气水合物预测模型研究的进展[J]. , 2006, 13(4): 1-.
[10]	李登伟　张烈辉　郭了萍　熊钰　梁雪原. 微波开采天然气水合物气藏技术[J]. , 2005, 12(6): 1-.
[11]	叶爱杰　孙敬杰　贾宁　白云程. 天然气水合物及其勘探开发方法[J]. , 2005, 12(1): 1-.
[12]	朱秋格. 天然气水合物--21世纪的潜在能源[J]. , 2004, 11(1): 1-.