稠油油藏注CO2+降黏剂过程中流体赋存特征及协同增效机理研究

doi:10.3969/j.issn.1006-6535.2025.06.014

特种油气藏 ›› 2025, Vol. 32 ›› Issue (6): 116-123.DOI: 10.3969/j.issn.1006-6535.2025.06.014

稠油油藏注CO₂+降黏剂过程中流体赋存特征及协同增效机理研究

章杨¹, 王晓燕¹, 王海峰¹, 张祖峰¹, 张楠¹, 鲍磊¹, 庞占喜²

1.中国石油大港油田分公司,天津 300280;
2.中国石油大学北京,北京 102249

收稿日期:2024-07-24 修回日期:2025-09-02 出版日期:2025-12-25 发布日期:2025-12-31
通讯作者: 庞占喜(1977—),男,教授,2002年毕业于石油大学(华东)石油工程专业,2008年毕业于中国石油大学(北京)油气田开发工程专业,获博士学位,现从事稠油油藏开发和数值模拟研究工作。
作者简介:章杨(1987—),男,高级工程师,2010年毕业于中国石油大学(华东)石油工程专业,2016年毕业于该校油气井工程专业,获博士学位,现从事注气提高采收率方面的研究工作。
基金资助:
国家自然科学基金面上项目“多孔介质中纳米颗粒与发泡剂协同构建Pickering泡沫机制及其运移规律”(52074321)

Characteristics of fluid distribution and synergistic enhancement mechanisms during CO₂+viscosity-reducing agent injection in heavy oil reservoirs

ZHANG Yang¹, WANG Xiaoyan¹, WANG Haifeng¹, ZHANG Zufeng¹, ZHANG Nan¹, BAO Lei¹, PANG Zhanxi²

1. PetroChina Dagang Oilfield Company,Tianjin 300280,China;
2. China University of PetroleumBeijing,Beijing 102249,China

Received:2024-07-24 Revised:2025-09-02 Online:2025-12-25 Published:2025-12-31

摘要/Abstract

摘要： 针对中深层稠油油藏热采开发难度大、采收率低的问题,根据CO₂在稠油中的溶解特性和降黏剂的作用原理,基于微观渗流模拟技术,开展协同降黏机理实验和协同增效机理实验,研究CO₂及CO₂+降黏剂协同作用提高稠油采收率机理。实验表明:在油藏条件下,CO₂可溶于稠油,形成直径为0.016～0.051 mm的微小泡沫油,显著改善原油流动性,驱替后波及系数达到56.4%,采出程度达到37.3%;降黏剂可使原油形成微细的乳状液滴,扩大CO₂波及范围,降黏率超过99.0%,波及系数达到65.3%,采出程度达到46.2%。研究表明:CO₂通过溶解膨胀和显著降黏作用改善原油流动能力,其与降黏剂的协同作用能大幅度提升驱油效率和波及范围;泡沫油的形成和乳状液滴的封堵是提高波及效率的关键机制。该研究对中深层稠油油藏提高原油采收率及实现CO₂地质封存具有重要的实践指导意义。

关键词: 稠油油藏, CO₂, PVT实验, 可视化实验, 波及效率, 协同增效

Abstract: Faced with the difficulties of thermal development and low recovery in mid-deep heavy oil reservoirs,and based on the CO₂ solubility in heavy oil and the operational principle of viscosity-reducing agents,micro-scale flow simulations were conducted involving synergistic viscosity reduction and enhanced production experiments.The study examined the mechanism by which CO₂ and CO₂+viscosity-reducing agent jointly improved heavy oil recovery.Experimental results showed that under reservoir conditions,CO₂ dissolved in heavy oil to form minute CO₂-in-oil bubbles(0.016-0.051 mm in diameter),significantly improving crude oil mobility;after displacement,the swept coefficient reached 56.4% and oil recovery degree 37.3%.The viscosity-reducing agent caused crude oil to form fine emulsion droplets,expanding the CO₂ sweep area;the viscosity reduction rate exceeded 99.0%,and the swept coefficient reached 65.3%,with recovery up to 46.2%.This indicated that CO₂ improved oil flowability via solution-induced expansion and viscosity reduction,and its synergistic action with the viscosity-reducing agent could substantially enhance displacement efficiency and sweep extent.The formation of foam oil and blockages by emulsified droplets were the key mechanisms improving sweep efficiency.This study provides practical guidance for enhancing recovery in mid-deep heavy oil reservoirs and for realizing CO₂ geological styorage.

Key words: heavy oil reservoir, CO₂, PVT experiment, visualization experiment, sweep efficiency, synergistic enhancement

中图分类号:

TE345

章杨, 王晓燕, 王海峰, 张祖峰, 张楠, 鲍磊, 庞占喜. 稠油油藏注CO₂+降黏剂过程中流体赋存特征及协同增效机理研究[J]. 特种油气藏, 2025, 32(6): 116-123.

ZHANG Yang, WANG Xiaoyan, WANG Haifeng, ZHANG Zufeng, ZHANG Nan, BAO Lei, PANG Zhanxi. Characteristics of fluid distribution and synergistic enhancement mechanisms during CO₂+viscosity-reducing agent injection in heavy oil reservoirs[J]. Special Oil & Gas Reservoirs, 2025, 32(6): 116-123.

参考文献

[1] 袁士义,王强.中国油田开发主体技术新进展与展望[J].石油勘探与开发,2018,45(4):657-668.
YUAN Shiyi,WANG Qiang.New progress and prospect of oilfields development technologies in China[J].Petroleum Exploration and Development,2018,45(4):657-668.
[2] 何万军,孙新革,吴永彬,等.浅层超稠油油藏双水平井SAGD电加热预热启动参数优化设计与矿场试验[J].特种油气藏,2024,31(6):77-83.
HE Wanjun,SUN Xin′ge,WU Yongbin,et al.Optimization design and field test of SAGD electric heating preheating start-up parameters for double horizontal wells in shallow super-heavy oil reservoirs[J].Special Oil & Gas Reservoirs,2024,31(6):77-83.
[3] 于建梅,韦涛,杜殿发,等.稠油油藏热化学驱油体系扩散规律[J].特种油气藏,2024,31(1):109-115.
YU Jianmei,WEI Tao,DU Dianfa,et al.Diffusion law of thermochemical oil displacement system for heavy oil reservoirs[J].Special Oil & Gas Reservoirs,2024,31(1):109-115.
[4] 吴永彬,刘雪琦,杜宣,等.超稠油油藏溶剂辅助重力泄油机理物理模拟实验[J].石油勘探与开发,2020,47(4):765-771.
WU Yongbin,LIU Xueqi,DU Xuan,et al.Scaled physical experiments on drainage mechanisms of solvent-expanded SAGD in super-heavy oil reservoirs[J].Petroleum Exploration and Development,2020,47(4):765-771.
[5] 张岩,冯海顺,翟勇,等.低渗透稠油油藏CO₂压驱提高采收率机理及规律研究[J].石油钻探技术,2024,52(6):97-106.
ZHANG Yan,FENG Haishun,ZHAI Yong,et al.Mechanism and law of CO₂ pressure flooding in enhancing oil recovery in low-permeability heavy oil reservoirs[J].Petroleum Drilling Techniques,2024,52(6):97-106.
[6] ZHOU X,LI X L,SHEN D H,et al.CO₂ huff-n-puff process to enhance heavy oil recovery and CO₂ storage:an integration study[J].Energy,2021,239(Part B):122003.
[7] WANG H Y,TORABI F,ZENG F H,et al.Experimental and numerical study of non-equilibrium dissolution and exsolution behavior of CO₂ in a heavy oil system utilizing Hele-Shaw-like visual cell[J].Fuel,2020,270:117501.
[8] 伦增珉,王海涛,张超,等.稠油油藏CO₂与化学剂协同强化蒸汽驱机制[J].中国石油大学学报(自然科学版),2023,47(6):72-79.
LUN Zengmin,WANG Haitao,ZHANG Chao,et al.Mechanisms of synergistic enhancement of steam flooding by CO₂ and chemical agents in heavy oil reservoirs[J].Journal of China University of Petroleum(Edition of Natural Science),2023,47(6):72-79.
[9] ZHOU X,ZENG F H.,ZHANG L H,et al.Experimental and mathematical modeling studies on foamy oil stability using a heavy oil-CO₂ system under reservoir conditions[J] ,Fuel,2020,264:116771.
[10] 靖波,华朝,侯胜珍,等.二氧化碳响应型表面活性剂与稠油的相互作用[J].油田化学,2023,40(1):81-86,92.
JING Bo,HUA Zhao,HOU Shengzhen,et al.Interaction between carbon dioxide responsive surfactant and heavy oil[J].Oilfield Chemistry,2023,40(1):81-86,92.
[11] 吴光焕,夏志增,时凤霞,等.CO₂对超稠油物性影响的实验研究[J].油田化学,2015,35(1):64-71.
WU Guanghuan,XIA Zhizeng,SHI Fengxia,et al.Effect of CO₂ on physical properties of super heavy oil[J].Oilfield Chemistry,2015,35(1):64-71.
[12] 王伟,高强,桂霞,等.二氧化碳在稠油中溶解度的测定与模型预测[J].化工学报,2016,67(2):442-447.
WANG Wei,GAO Qiang,GUI Xia,et al.Determination and model prediction of solubilities of CO₂ in heavy oil under high pressure[J].CIESC Journal,2016,67(2):442-447.
[13] 杨爽,李传宪,李庆一,等.超临界CO₂处理后草桥稠油流动性能及沥青质缔合状态的变化[J].石油学报(石油加工),2016,32(6):1171-1177.
YANG Shuang,LI Chuanxian,LI Qingyi,et al.The association state of asphaltene & flowing properties of Caoqiao heavy oil after gas-separation by supercritical CO₂[J].Acta Petrolei Sinica(Petroleum Processing Section),2016,32(6):1171-1177.
[14] 曹长霄,宋兆杰,师耀利,等.吉木萨尔页岩油二氧化碳吞吐提高采收率技术研究[J].特种油气藏,2023,30(3):106-114.
CAO Changxiao,SONG Zhaojie,SHI Yaoli,et al.Study on CO₂ huff-n-puff enhanced recovery technology for Jimsar shale oil[J].Special Oil & Gas Reservoirs,2023,30(3):106-114.
[15] 王一平,孙业恒,吴光焕,等.超深层稠油二氧化碳吞吐渗流规律[J].特种油气藏,2017,24(4):142-146.
WANG Yiping,SUN Yeheng,WU Guanghuan,et al.Permeability rule of CO₂ huff-n-puff for ultra-deep heavy oil reservoirs[J].Special Oil & Gas Reservoirs,2017,24(4):142-146.
[16] 崔传智,李安慧,吴忠维,等.基于物质平衡方程的CO₂理论构造埋存量计算新方法[J].特种油气藏,2023,30(1):74-78.
CUI Chuanzhi,LI Anhui,WU Zhongwei,et al.A new method for calculating the theoretical tectonic CO₂ storage volume based on material balance equation[J].Special Oil & Gas Reservoirs,2023,30(1):74-78.
[17] 吴润楠,魏兵,邹鹏,等.超临界CO₂对普通稠油和超稠油物性的影响规律[J].油田化学,2018,35(3):440-446.
WU Runnan,WEI Bing,ZOU Peng,et al.Effect of supercritical CO₂ on the physical properties of conventional heavy oil and extra-heavy oil[J].Oilfield Chemistry,2018,35(3):440-446.
[18] 曹成,李宇,张烈辉,等.润湿性对CO₂溶解封存的影响机制与调控方法研究进展[J].天然气工业,2024,44(12):162-175.
CAO Cheng,LI Yu,ZHANG Liehui,et al.Research progress on influence mechanism and control method of wettability on CO₂ dissolution storage[J].Natural Gas Industry,2024,44(12): 162-175.
[19] 王晓燕,章杨,张杰,等.稠油油藏注CO₂吞吐提高采收率机制[J].中国石油大学学报(自然科学版),2021,45(6):102-111.
WANG Xiaoyan,ZHANG Yang,ZHANG Jie,et al.EOR mechanisms of CO₂ huff and puff process for heavy oil recovery[J].Journal of China University of Petroleum(Edition of Natural Science),2021,45(6):102-111.
[20] 李晓骁,岳湘安,闫荣杰,等.稠油油藏表面活性剂辅助CO₂驱油效果及主控性能[J].油气地质与采收率,2021,28(6):94-100.
LI Xiaoxiao,YUE Xiang′an,YAN Rongjie,et al.Study on effect of surfactant-assisted CO₂ and dominatingbehavior of surfactant in heavy oil reservoirs[J].Petroleum Geology and Recovery Efficiency,2021,28(6):94-100.
[21] 甄贵男,王健,吴宝成,等.稠油油藏水气交替诱导泡沫油冷采提高采收率实验[J].特种油气藏,2024,31(1):101-108.
ZHEN Guinan,WANG Jian,WU Baocheng,et al.Enhanced oil recovery experiment of foam oil cold recovery induced by water-alternating-gas injection in heavy oil reservoirs[J].Special Oil & Gas Reservoirs,2024,31(1):101-108.

稠油油藏注CO₂+降黏剂过程中流体赋存特征及协同增效机理研究

Characteristics of fluid distribution and synergistic enhancement mechanisms during CO₂+viscosity-reducing agent injection in heavy oil reservoirs

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	孙艳坤, 孙天宇, 朱天元, 龙涛, 周良昌, 彭鹏. 空-天-地-井一体化监测技术在CO₂地质封存泄漏监测中的研究进展[J]. 特种油气藏, 2025, 32(6): 1-13.
[2]	王梓麟, 朱卫平, 徐栋, 王玉斌, 陈萌琦, 焦晗, 刘川庆, 何朋勃. 鄂尔多斯盆地大吉区块深层煤岩气前置CO₂泡沫压裂技术[J]. 特种油气藏, 2025, 32(6): 158-164.
[3]	胡义升, 陈继宏, 成秋荣, 蒲磊, 郭平. 低渗透油藏CO₂驱高温高压微观可视化实验[J]. 特种油气藏, 2025, 32(5): 137-145.
[4]	毕卫宇, 何治武, 王智勇, 周佩, 王小勇, 刘笑春. 低温固化型甲基丙烯酸甲酯树脂井筒修复体系的优选与评价[J]. 特种油气藏, 2025, 32(5): 167-174.
[5]	刘志远, 赵海峰, 甘贵鹏, 张旺. 基于转向临界能量的超低渗透油藏注CO₂气窜缝网形成机理[J]. 特种油气藏, 2025, 32(4): 94-103.
[6]	王泊, 李德儒, 唐磊, 李长宏, 赵长喜, 郝丽娜, 曲涵, 邓浩坤. 多周期蒸汽吞吐井间汽窜评价方法及治理对策[J]. 特种油气藏, 2025, 32(4): 112-121.
[7]	邓佳男, 郑昊, 高源鲜, 毕文良, 赵鸿浩, 贺甲元, 卢贵武, 张潇. CO₂响应型预交联凝胶颗粒的研制及性能评价[J]. 特种油气藏, 2025, 32(2): 110-116.
[8]	樊阳杰, 付美龙, 刘漪雯, 李国俊, 宿志昊. CO₂羽流地热系统与水基增强型地热系统换热效果对比实验[J]. 特种油气藏, 2025, 32(2): 117-122.
[9]	王典, 李军, 连威, 刘献博, 张俊成, 郭少坤. CO₂封存地层压力演化规律及影响因素分析[J]. 特种油气藏, 2025, 32(2): 168-174.
[10]	郭发军, 梁飞, 陈洪, 齐桓, 曾庆桥, 王睿思, 李宜强, 吴永恩. 潜山油藏CO₂重力混相驱作用机制与驱油实验[J]. 特种油气藏, 2025, 32(1): 98-105.
[11]	王程伟, 苏玉亮, 王文东, 李蕾, 郝永卯. CO₂-C₂H₆提高原油萃取及混相能力研究[J]. 特种油气藏, 2025, 32(1): 113-119.
[12]	牛子敬, 赵忠军, 张园, 胡景宏. 考虑变周期注气量和经济效益的致密油藏CO₂吞吐注采参数优化[J]. 特种油气藏, 2024, 31(6): 114-119.
[13]	王香增, 陈小凡, 李剑, 陈芳萍, 范庆振, 王剑. 一种基于“四区”的低渗透油藏CO₂埋存量计算方法及应用[J]. 特种油气藏, 2024, 31(3): 78-84.
[14]	姚同玉, 孙灵辉, 崔传智. 扶余致密油藏CO₂吞吐参数优化设计[J]. 特种油气藏, 2024, 31(3): 123-128.
[15]	孙梓齐, 赵仁保, 王田田, 龙海庆, 黄田, 陈昌剑. 次生水体对火驱开发效果影响的实验[J]. 特种油气藏, 2024, 31(2): 120-128.