火驱原油活性氢组分变化规律认识

doi:10.3969/j.issn.1006-6535.2022.06.016

摘要/Abstract

摘要： 为识别火驱开发中是否发生高温氧化以及高温氧化程度,应用实沸点蒸馏法对新疆油田红浅试验区火驱受效前后的原油进行分离,绘制相应的实沸点蒸馏曲线,测定各馏分的酸值,并用超高分辨质谱仪对不同类型酸性化合物在负离子模式电喷雾电离源条件下进行分析,对O2类组分的等效双键指数(DBE)和碳数分布进行了详细归类。结果表明:虽然火驱受效前后原油酸值波动范围小于1.0 mg/g,但受效原油中的中低沸点组分含量和实沸点蒸馏质量收率明显提高,受效原油的部分组分氧化生成了含有活性氢官能团的化合物,在200～250 ℃、300～420 ℃沸点范围出现2个波峰;质谱分析表明,火驱见效原油O2类组分中DBE为3和4的相对丰度增大,二元、三元环烷酸占比增加。研究成果可为分析原油火驱过程和馏分产品精制提供指导。

关键词: 火驱, 原油组分, 氢组分变化, 实沸点蒸馏, 等效双键指数, O2类

Abstract: In order to enrich the methods for identifying whether high temperature oxidation occurs and the degree of high temperature oxidation during the fire flooding development, the real boiling point distillation method was applied to separate the crude oil before and after the effectiveness of fire flooding in Hongqian Area of Xinjiang Oilfield, the corresponding real boiling point distillation curves were plotted, and the acid value of each fraction was measured. The high-resolution mass spectrometry was used to analyze different types of acidic compounds under the condition of electrospray ionization source in negative ion mode, and the equivalent double bond index (DBE) and carbon number distribution of O2-type components were classified in details. The results show that although the fluctuation range of the acid value of crude oil before and after the effectiveness of fire flooding is less than 1.0 mg/g, the content of low and medium boiling point components in the effected crude oil and the yield of real boiling point distillation mass are significantly improved, some components of the effected crude oil are oxidized to generate compounds containing active hydrogen functional groups, and two peaks appeared in the boiling point range of 200-250 ℃and 300-420 ℃. The mass spectrometry analysis shows that the relative abundances of DBE 3 and 4 in the O2 components of the fire flooding effected crude oil increases, and the proportion of two-membered and three-membered naphthenic acids increases. The research results can provide guidance for the analysis of crude oil fire flooding process and the refining of distillate products.

Key words: fire flooding, crude oil component, hydrogen component change, real boiling point distillation, equivalent double bond index, O2 type

中图分类号:

TE622

杨洪, 苏日古, 陈莉娟, 王旭生, 陈龙, 潘竟军, 郭勇. 火驱原油活性氢组分变化规律认识[J]. 特种油气藏, 2022, 29(6): 127-132.

Yang Hong, Su Rigu, Chen Lijuan, Wang Xusheng, Chen Long, Pan Jingjun, Guo Yong. Recognition of Variation Law of Active Hydrogen Component of Fire-Flooded Crude Oil[J]. Special Oil & Gas Reservoirs, 2022, 29(6): 127-132.

参考文献

[1] 王元基,何江川,廖广志,等.国内火驱技术发展历程与应用前景[J].石油学报,2012,33(5):909-914.
WANG Yuanji,HE Jiangchuan,LIAO Guangzhi,et al.Overview on the development history of combustion drive and its application prospect in China[J].Acta Petrolei Sinica,2012,33(5):909-914.
[2] 廖广志,王红庄,王正茂,等.注空气全温度域原油氧化反应特征及开发方式[J].石油勘探与开发,2020,47(2):334-340.
LIAO Guangzhi,WANG Hongzhuang,WANG Zhengmao,et al.Oil oxidation in the whole temperature regions during oil reservoir air injection and development methods[J].Petroleum Exploration and Development,2020,47(2):334-340.
[3] 霍进,赵仁保,孙新革,等.火驱技术国内外进展及理论发展方向的思考[J].新疆石油天然气,2021,17(3):30-36.
HUO Jin,ZHAO Renbao,SUN Xin'ge,et al.Progress of ISC technology and perspective on the future work of its theoretical research[J].Xinjiang Oil & Gas,2021,17(3):30-36.
[4] 彭小强,韩晓强,张继周,等.稠油油藏火驱驱油特征研究[J].新疆石油天然气,2016,12(4):64-68.
PENG Xiaoqiang,HAN Xiaoqiang,ZHANG Jizhou,et al.Studying on in-situ combustion flooding behavior for heavy oil reservoirs[J].Xinjiang Oil & Gas,2016,12(4):64-68.
[5] 张方礼,户昶昊,马宏斌,等.辽河油田火驱开发技术进展[J].特种油气藏,2020,27(6):12-19.
ZHANG Fangli,HU Changhao,MA Hongbin,et al.Development of fire flooding technology in Liaohe Oilfield[J].Special Oil & Gas Reservoirs,2020,27(6):12-19.
[6] 蔡文斌,李友平,李淑兰,等.胜利油田火烧油层现场试验[J].特种油气藏,2007,14(3):88-90,110.
CAI Wenbin,LI Youping,LI Shulan,et al.Field test of in situ combustion in Shengli Oilfield[J].Special Oil & Gas Reservoirs,2007,14(3):88-90,110.
[7] 赵睿智,陈明贵,高飞,等.厚层稠油油藏直平组合火驱优化[J].断块油气田,2020,27(2):233-237.
ZHAO Ruizhi,CHEN Minggui,GAO Fei,et al.In-situ combustion optimization of vertical and horizontal wells combination for heavy oil reservoirs with thick layer[J].Fault-Block Oil & Gas Field,2020,27(2):233-237.
[8] 张鸿.边底水稠油油藏火驱可行性及操作参数优选实验研究[J].石油地质与工程,2020,34(5):74-78.
ZHANG Hong.Experimental study on feasibility of fire flooding and optimization of operation parameters in heavy oil reservoir with edge and bottom water[J].Petroleum Geology & Engineering,2020,34(5):74-78.
[9] 蒋海岩,李天月,杜坤,等.火驱过程中稠油组分变化特征研究[J].特种油气藏,2021,28(4):96-101.
JIANG Haiyan,LI Tianyue,DU Kun,et al.Study on the characteristics of changes in heavy oil components during in-sutu combustion[J].Special Oil & Gas Reservoirs,2021,28(4):96-101.
[10] 户昶昊.火驱高温与低温氧化转换界限研究[J].特种油气藏,2021,28(1):86-92.
HU Changhao.Study on transform boundary of high-temperntwe and low-temperature oxidation in in-situ Combustion[J].Special Oil & Gas Reserviors,2021,28(1):86-92.
[11] 才业.水淹稠油油藏火驱开发受效特征研究[J].特种油气藏,2020,27(5):125-131.
CAI Ye.Study on the response characteristics of fire flooding in water-flooded heavy oil reservoirs[J].Special Oil & Gas Reservoirs,2020,27(5):125-131.
[12] 蒋海岩,李晓倩,高成国,等.火驱阶段特征对比与分析[J].油气藏评价与开发,2020,10(5):114-119.
JIANG Haiyan,LI Xiaoqian,GAO Chengguo,et al.Comparison and analysis of stage feature of in situ combustion[J].Reservoir Evaluation and Development,2020,10(5):114-119.
[13] ZHAO R B,ZHANG C,YANG F X,et al.Influence of temperature field on rock and heavy components variation during in-situ combustion process[J].Fuel,2018,230:244-257.
[14] 蒋海岩,袁士宝,李杨,等.稠油氧化阶段划分及活化能的确定[J].西南石油大学学报(自然科学版),2016,38(4):136-142.
JIANG Haiyan,YUAN Shibao,LI Yang,et al.Division of oxidation stage of heavy oil in the process of in-situ combustion[J].Journal of Southwest Petroleum University (Science & Technology Edition),2016,38(4):136-142.
[15] 王正茂,廖广志,蒲万芬,等.注空气开发中地层原油氧化反应特征[J].石油学报,2018,39(3):314-319.
WANG Zhengmao,LIAO Guangzhi,PU Wanfen,et al.Oxidation reaction features of formation crude oil in air injection development[J].Acta Petrolei Sinica,2018,39(3):314-319.
[16] 高成国,木合塔尔,展宏洋,等.克拉玛依油田红浅区火驱燃烧前缘的确定[J].新疆石油地质,2020,41(2):188-192.
GAO Chengguo,Muhtar,ZHAN Hongyang,et al.Monitoring and description methods of fire flooding combustion front in Hongqian Area,Karamay Oilfield[J].Xinjiang Petroleum Geology,2020,41(2):188-192.
[17] 梁建军,计玲,蒋西平,等.克拉玛依油田红浅火驱先导试验区火驱开发节能效果[J].新疆石油地质,2017,38(5):599-601.
LIANG Jianjun,JI Ling,JIANG Xiping,et al.Energy-saving effect of fireflooding development in Hongqian pilot test area of Karamay Oilfield[J].Xinjiang Petroleum Geology,2017,38(5):599-601.
[18] LI Y Y,LIAO G Z,WANG Z M,et al.Molecular composition of low-temperature oxidation products in a simulated crude oil In-situ combustion[J].Fuel,2022,316:123297.
[19] 马永明.SBD-V蒸馏仪在原油评价中的应用[J].山东化工,2019,48(1):108-111.
MA Yongming.Application of SBD-V distillation apparatus in crude oil evaluation[J].Shandong Chemical Industry,2019,48(1):108-111.
[20] 中国能源局.岩石中可溶有机物及原油族组分分析:SY/T 5119—2016[S].北京:石油工业出版社,2016:1-8.
National Energy Administration.Analysis of soluble organic matter and crude oil group composition in rocks:SY/T 5119-2016[S].Beijing:Petroleum Industry Press,2016:1-8.
[21] 中国国家质量监督检验检疫总局.原油蒸馏标准试验方法:GB/T 17280—2009[S].北京:中国标准出版社,2009:1-53.
General Administration of Quality Supervision,Inspection and Quarantine of the People's Republic of China.Standard test method for distillation of crude petroleum:GB/T 17280—2009[S].Beijing:Standards Press of China,2009:1-53.
[22] 中国石油塔里木油田分公司.原油酸值测定方法:Q/SY TZ 0021—2000[S].北京:石油工业出版社,2000:1-7.
PetroChina Tarim Oilfield Company.Crude oil acid value determination method:Q/SY TZ 0021-2000[S].Beijing:Petroleum Industry Press,2000:1-7.
[23] SHI Q,PAN N,LONG H,et al.Characterization of middle-temperature gasification coal tar.part 3:molecular composition of acidic compounds[J].Energy Fuels,2013,27:108-117.
[24] SHI Q,DONG Z Y,ZHANG Y H,et al.Data processing of high-resolution mass spectra for crude oil and its distillations[J].Journal of Instrumental Analysis,2008,27:246-248.
[25] MEREDITH W,KELLAND S J,JONES D M.Influence of biodegradation on crude oil acidity and carboxylic acid composition[J].Org Geochem,2000,31(11):1059-1073.